Roberts Gorden System Control HP 208 V 3 - Manual (Page 3)

© 2009 Roberts-Gordon LLC
All rights reserved. No part of this work covered by the copyrights herein may be reproduced
or copied in any form or by any means - graphic, electronic, or mechanical, including
photocopying, recording, taping or information storage and retrieval systems - without the
written permission of Roberts-Gordon LLC.
TABLE OF CONTENTS
SECTION 1: Introduction........................................................ 1
1.1 Safety ........................................................................... 1
1.2 What is a ROBERTS GORDON
® System Control? ...... 1
1.3 Electrical Requirements ............................................... 1
1.4 Check Installation Materials ......................................... 1
SECTION 2: Specifications .................................................... 3
2.1 Material Specifications................................................. 3
2.2 Electrical Specifications ............................................... 3
2.3 Pump Specifications .................................................... 3
2.4 Burner Electrical Ratings ............................................. 4
2.5 Outside Air Supply Blower Electrical Ratings .............. 4
2.6 Indicator Lights ............................................................ 4
2.7 Terminal Block Guide................................................... 4
SECTION 3: Installation.......................................................... 5
3.1 Preparation .................................................................. 5
3.2 Installing the System Control Panel ............................. 5
3.3 Select the External Wiring Diagram for the
Installation.................................................................... 5
3.4 System Configuration................................................... 6
SECTION 4: Typical External Wiring Diagrams .................... 7
4.1 EP-100 or EP-201 120 V 1 Ø Pump External
Wiring Diagram............................................................ 7
4.2 EP-201 or EP-301 230 V 1 Ø External
Wiring Diagram............................................................ 8
4.3 EP-203 or EP-303 208 - 230 V (or 460 V) 3 Ø Pump
External Wiring Diagram.............................................. 9
4.4 Outside Air Blower External Wiring Diagram ............. 10
SECTION 5: Troubleshooting............................................... 12
5.1 Sequence of Operation.............................................. 12
SECTION 6: Replacement Parts .......................................... 14
6.1 Replacement Parts Instructions................................. 15
SECTION 7: The ROBERTS GORDON ® System Control
Warranty ........................................................... 17
Printed in U.S.A.