Volvo 960 User Manual
Page 212
1996 Volvo 960
Deep scars
If the stone chip has been penetrated down to the metal, proceed as follows:
1 Place a strip of masking tape over the damaged surface. Pull the tape off so that any loose flakes of
paint adhere to it.
2 Thoroughly mix the primer and apply it with a small brush.
When the primer surface is dry, the paint can be applied using a brush.
Mix the paint thoroughly: apply several thin paint coats and let dry each application.
3 If there is a longer scratch, you may want to protect surrounding paint by masking it off.
NOTE: When touching up the car, it should be cleaned and dry. The surface temperature should be
above 60°F (+15°C).
pg. 7:4 Washing
Washing the car
The car should be washed at regular intervals since dirt, dust, insects and tar spots adhere to the paint
and may cause damage.
When washing the car, do not expose it to direct sunlight. Use lukewarm water to soften the dirt before
you wash with a sponge, and plenty of water, to avoid scratching.
A detergent can be used to facilitate the softening of dirt and oil. A water-soluble grease solvent may be
file:///K|/ownersdocs/1996/1996_960/96960_701.htm (4 of 7)12/30/2006 10:13:06 AM