ACR Electronics Nauticast Y1-03-0212 User Manual
Page 3
Installation Manual
III
Y1-03-0212 Rev. E
1
GENERAL INTRODUCTION ...............................................................................................................................................1
1.1
Description of AIS ......................................................................................................................................................1
1.2
AIS in an Operational Environment ............................................................................................................................2
1.3
AIS Networks .............................................................................................................................................................3
2
NAUTICAST ........................................................................................................................................................................4
2.1
System Overview .......................................................................................................................................................4
3
INSTALLATION ...................................................................................................................................................................5
3.1
Installation Requirements ...........................................................................................................................................5
3.2
Installation Overview ..................................................................................................................................................5
3.3
General Interface Description .....................................................................................................................................7
3.4
Interface NMEA Description: ......................................................................................................................................8
3.4.1
Sensor - Interface CH1, CH2, CH3 ...................................................................................................................8
3.4.2
ECDIS
– Presentation Interface CH 4 ...............................................................................................................8
3.4.3
Pilot Port CH 5 .................................................................................................................................................9
3.4.4
Long Range CH 8 ............................................................................................................................................9
3.4.5
DGPS
– DGNSS Channel 9 ........................................................................................................................... 10
3.4.6
Alarm Circuit
– BIIT Channel 10 ..................................................................................................................... 10
3.4.7
Proprietary Sentences .................................................................................................................................... 10
3.5
Sensor Interface Definitions ..................................................................................................................................... 11
3.5.1
Talker drive circuits ........................................................................................................................................ 11
3.5.2
Listener Receiver Circuits ............................................................................................................................... 11
3.5.3
Electrical isolation .......................................................................................................................................... 11
3.5.4
Maximum voltage on the bus .......................................................................................................................... 11
3.5.5
Data transmission .......................................................................................................................................... 11
3.6
Sensor notes............................................................................................................................................................ 12
3.7
Sensor Hardware Installation: .................................................................................................................................. 13
3.7.1
Installation of an RS422 serial interface:......................................................................................................... 13
3.8
Sensor Software Configuration ................................................................................................................................ 14
3.8.1
Introduction .................................................................................................................................................... 14
3.8.2
Set up Sensor Speed, Checksum (CRC) and NMEA Talker and Sentence ID ................................................ 14
3.8.3
Real-Time Analysis of NMEA Data Streams ................................................................................................... 17
3.8.4
Sensor Monitoring for Problem Analysis ......................................................................................................... 19
3.8.5
Priority Handling of Sensor Sentence ............................................................................................................. 20
3.8.6
Supported NMEA-0183 Sentences ................................................................................................................. 20
3.8.7
Calculated Values .......................................................................................................................................... 23
3.8.8
Versions of NMEA Sentences ........................................................................................................................ 24
3.9
Pin-Description AIS-Cable / Socket 50-Pins: ............................................................................................................ 25
3.10
Pin-Description AIS-Connector: ........................................................................................................................... 26
3.11
Pin-Description Communication-Cable / Socket 50-Pins ..................................................................................... 27
3.12
Communication Cable RS232 (Sub-D 50 Socket) ............................................................................................... 28
3.13
Installation of VHF / GPS Antennas ..................................................................................................................... 29
3.13.1
VHF Antenna Installation ................................................................................................................................ 29
3.13.2
GNSS Antenna installation ............................................................................................................................. 30
3.14
Power Supply ...................................................................................................................................................... 31
4
STARTING THE NAUTICAST ........................................................................................................................................... 32
4.1
Initial Set Up of the NAUTICAST for operation ......................................................................................................... 32
4.2
Entering the MMSI / IMO / DAC / ESN Numbers ...................................................................................................... 33
4.3
Entering Ship Settings ............................................................................................................................................. 36
4.4
Entering Voyage Related Data ................................................................................................................................. 38
4.5
Entering Inland AIS Configuration ............................................................................................................................ 42
4.6
Service and User Passwords ................................................................................................................................... 44
5
TROUBLESHOOTING ....................................................................................................................................................... 47
5.1
Reading and understanding Alarms: ........................................................................................................................ 47
5.2
Alarm Codes ............................................................................................................................................................ 48
5.3
Text Messages ....................................................................................................................................................... 49
5.4
Restarting the NAUTICAST...................................................................................................................................... 49
6
ACCESSORIES................................................................................................................................................................. 50
7
TECHNICAL INFORMATION ............................................................................................................................................ 51
7.1
ERI Ship Types ........................................................................................................................................................ 52
8
CONTACT AND SUPPORT INFORMATION ..................................................................................................................... 53
9
APPENDIX ........................................................................................................................................................................ 54
9.1
Samples for battery calculation ................................................................................................................................ 54
9.1.1
Typical Installation .......................................................................................................................................... 54
9.1.2
RM GMDSS Compact-Console Area A3 with 250 W MF/HF........................................................................... 55
9.1.3
RM GMDSS Compact-Console Area A3 with 400 W MF/HF........................................................................... 55
9.2
Drawings and Approvals .......................................................................................................................................... 56
NAUTICAST-INLAND Installation Manual
Index
Page Number