Snorkel UL40 - Manual (Page 8)

8
Specifications*
ROUTINE SERVICE
Use the following table as a guide for routine maintenance, refer to Service Manual for complete service
instructions.
SERVICE OPERATION INTERVAL
MONTHLY 3 MONTHS YEARLY
DAILY OR OR OR
50 HRS. 125 HRS. 500 HRS.
Check bubble level accuracy X
Check operation of outrigger interlocks X
Check battery fluid level and charge battery (D.C. models only) X
Check for peeling, faded or missing labels & replace X
Check condition of control cable X
Inspect mast assembly for bends, cracks or loose rivets X
Check chassis and platform emergency stop switch operation X
Check emergency lowering valve operation X
Check casters for damage X
Check hydraulic fluid level X
Check cage and cage support fasteners for proper torque X
Inspect and adjust sequence straps slack X
Lubricate lift chains and sheaves X
Change hydraulic fluid (ISO #46) X
068017-000 Rev. 1 06/02
FOR MORE INFORMATION
Local Distributor:
TEL: (800) 926-5438 or (559) 662-3900
FAX: (559) 662-6184
PARTS FAX: (559) 669-9884
801 S. Pine St., Madera, CA 93637
Safety
Rules
and
Operating
Instructions
Safety
Rules
and
Operating
Instructions
UL25
25 ft. (7.62 m)
15 in. (38 cm)
350 lbs. (159 kg)
78 in. (1.98 m)
29 in. (74 cm)
49.5 in. (1.26 m)
Opt 74.75 in (1.90m)
Opt 102 in (2.59m)
59 in. (1.5 m)
56 in. (1.42 m)
770 lbs. (349 kg)
810 lbs. (367 kg)
46 lbs. (21 kg)
64 lbs. (29 kg)
43.5 in. (1.1 m)
6 in. (152 mm)
UL32
32 ft. (9.75 m)
15 in. (38 cm)
300 lbs. (136 kg)
99.5 in. (2.53 m)
29 in. (74 cm)
52.5 in. (1.32 m)
78 in. (1.98 m)
99.5 in. (2.53 m)
81 in. (2.06 m)
78 in. (1.98 m)
920 lbs. (417 kg)
960 lbs. (435 kg)
54 lbs. (25 kg)
64 lbs. (29 kg)
43.5 in. (1.1 m)
6 in. (152 mm)
UL40
40 ft. (12.19 m)
15 in. (38 cm)
300 lbs. (136 kg)
114 in. (2.90 m)
29 in. (74 cm)
52.5 in. (1.32 m)
78 in. (1.98 m)
114 in. (2.9 m)
92 in. (2.34 m)
89 in. (2.26 m)
990 lbs. (449 kg)
1030 lbs. (467 kg)
66 lbs. (30 kg)
64 lbs. (29 kg)
43.5 in. (1.1 m)
6 in. (152 mm)
ITEM
Platform Height
Maximum
Minimum
Platform Capacity
Stored Dimensions
Vertical Height
Width
Depth
Tilted-Back Height
Tilted-Back Length
Footprint(outriggers extended)
Width
Length
Weight-overall
w/o Outriggers & Screwjacks
Set of Outriggers & Screwjacks
Addt'l Weight for D.C. Option
Guardrail Height
Toe Board Height
Max. System Voltage
AC Electric Motor
DC Electric Power Source
Battery Charger
Maximum Hydraulic System
Pressure
120 VAC 60 Hz or 220 VAC 50/60 Hz
1-12 Volt Battery, Grp. 27
105 Amp/Hrs., Min. Wt. 52 lbs. (23.6 kg)
Automatic, 120 VAC 60 Hz or 220 VAC 50 Hz
Output: 10 Amps, 12 Volts D.C.
2400 PSI (165 bar)
*Specifications subject to change without notice.
Meets or exceeds all applicable requirements of OSHA and ANSI A92.3-1990.