JLG 3246E2 ANSI Operator Manual - Manual (Page 19)

SECTION 2 - PREPARATION AND INSPECTION
3120736 – JLG Lift –
2-5
Figure 2-1. Daily Walk-Around Inspection - 2032E2/2632E2/2646E2/3246E2 (Sheet 2 of 3).
GENERAL
Begin the “Walk-Around Inspection” at Item 1, as noted
on the diagram. Continue to the right (counterclockwise
viewed from top) checking each item in sequence for the
conditions listed in the “Walk-Around Inspection Check-
list.”
TO AVOID INJURY DO NOT OPERATE MACHINE UNTIL ALL MAL-
FUNCTIONS HAVE BEEN CORRECTED. USE OF A MALFUNC-
TIONING MACHINE IS A SAFETY VIOLATION.
TO AVOID POSSIBLE INJURY, BE SURE MACHINE POWER IS
“OFF” DURING “WALK-AROUND INSPECTION.”
NOTE: Do not overlook visual inspection of chassis under-
side. Checking this area often results in discovery of
conditions which could cause extensive machine
damage.
1. Platform Controls - Properly secured; no loose or
missing parts; no visible damage to control box or
controller (joystick). Placards secure and legible;
control markings legible; operators and safety man-
ual in manual storage box.
2. Steer Cylinder and Linkage - Properly secured; no
loose or missing parts; no visible damage; no evi-
dence of steer cylinder leakage.
3. Safety Prop - Properly secured; no visible damage;
no loose or missing parts.
4. Scissor Arms and Sliding Wear Pads - Properly
secured; no loose or missing parts; no visible dam-
age.
5. Wheel and Tire Assembly, Left Front - Properly
secured; no loose or missing lug nuts; no visible
damage.
6. Drive Cutout Switch - Properly secured; no visible
damage; no loose or missing parts.
7. Compartment Cover and Latches - Cover and
latches in working condition; properly secured; no
loose or missing parts.
8. Ground Controls - No visible damage; switches
operable; placards secure and legible.
9. Hydraulic Reservoir - No visible damage; no loose
or missing parts; no evidence of leakage. Recom-
mended hydraulic fluid level on side of tank.
Breather cap secure and working.
10. Hydraulic Filter - No visible damage; properly
secured; no evidence of leakage.
11. Motor/Pump Unit - Properly secured; no visible
damage; no evidence of hydraulic leakage.
12. Pothole Protection System - Support broilers, limit
switches and links properly secured; no visible
damage; no loose or missing parts.
13. Hourmeter - No visible damage.
14. Wire Installation - No visible damage; no loose or
broken wires.
15. Control Valve Installation - No loose or missing
parts; no evidence of leakage; No unsupported
wires or hoses; no damaged or broken wires.
16. Wheel and Tire Assembly, Left Rear - Properly
secured; no loose or missing lug nuts; no visible
damage.
17. Drive Motor, Left Rear - Properly secured; no visible
damage; no evidence of leakage.
18. Scissor Arms and Sliding Wear Pads - Properly
secured; no visible damage; no loose or missing
parts.
19. Handle for Manual Descent Pump (2632/2646E2/
3246E2) - No visible damage.
20. Manual Descent Pump (2632/2646E2/3246E2) -
Properly secured; no visible damage; no evidence
of leakage;
21. Manual Descent Cable and Pull Handle (2032) - No
visible damage; Properly secured; no loose or miss-
ing parts.
22. Brake Cylinder - Properly secured; no visible dam-
age; no evidence of leakage.
23. Ladder - Properly secured; no visible damage; no
loose or missing hardware.
24. Scissor Arms and Sliding Wear Pads - Properly
secured; no visible damage; no loose or missing
parts.
25. Drive Motor, Right Rear - Properly secured; no visi-
ble damage; no evidence of leakage.
26. Wheel and Tire Assembly, Right Rear - Properly
secured; no loose or missing lug nuts; no visible
damage.
27. Lift Cylinder - Properly secured; no visible damage;
no loose or missing parts; no evidence of leakage.
28. Tilt Switch - Properly secured; no loose or missing
parts; no visible damage; no loose or broken wiring.