Carter-Hoffmann PHW1822 - Manual (Page 11)

11
DAILY CLEANING PROCEDURES
1. Clean cabinet regularly, using the following procedure:
2. Unplug cabinet and allow to completely before cleaning.
3. Each entire heating unit can be lifted out of
the cabinet prior to cleaning. Unplug the
heating units from the junction box. Grasp
the heater handle with one hand and the
rear of the heater unit with the other. Lift
heater up and then out. Do the same with
the other heater.
4. Racks or shelves may be removed for cleaning. Tools are re-
quired to removed the bolts at the top and bottom of each
rack. After removing the fasteners, simply lift up and pull out.
Hand wash the tray slides..
5. Vinyl trim should be washed with a chlorine-free detergent and
water. Rinse thoroughly with clear water and allow to dry.
Never use abrasive cleaners, waxes, car polish, or substances
containing strong aromatic solvents or alcohol. Use of direct
steam/hot water cleaning at temperatures above 190°F (88°C)
may result in bubbling or loosening of vinyl adhesive.
6. To clean stainless steel surfaces use only cleansers, deter-
gents, degreasers, or sanitizers that are certified to be
“chloride-free” and “phosphate-free”. DO NOT exceed recom-
mended concentrations or mixing ratios. After cleaning and
sanitizing, rinse all exposed surfaces thoroughly with large
amounts of clear water; since heaters have been removed,
cart may be rinsed with a hose. Wipe off any standing liquid or
residue from all horizontal surfaces, in corners, or near edges.
DO NOT TIP CABINET ONTO THE DOORS TO EMPTY EX-
CESS WATER.
7. Wipe dry with a clean soft cloth.
8. After cabinet is completely dry, replace heating units and re-
establish electrical connection to the junction box.
CAUTION : Beware
of sharp edges with
sheet metal during
cleaning process.
CAUTION:
ELECTRIC SHOCK
HAZARD
Disconnect appliance from
electric power before cleaning.
CAUTION:
HOT SURFACE
Exposed surfaces can
be hot to the touch and may
cause burns. Allow appliance
to cool before cleaning.
IMPORTANT:
DO NOT spill or pour
water into controls,
control panel or wiring. Water
damage is not covered by war-
ranty.
CAUTION : Do not
use steel wool pads
as they will result in
rusting from the ferrous metal
in the pads.
Electrical connection
to junction box at
base of cabinet.
Unplug and remove
heaters prior to
cleaning.
Water reservoir for humidified heater (right side) may be cleaned with mild detergent and water. Hard water
spots may be cleaned with vinegar. Rise with clean water and wipe dry. DO NOT IMMERSE HEATER IN WA-
TER OR SPRAY WATER ONTO THE HEATER. Water damage is not covered by the warranty.