E-Z-GO 602080 - Manual (Page 36)

OPERATION AND SERVICE INFORMATION
Page 20 Owner’s Manual and Service Guide
Read all of manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notes, Cautions and Warnings
AIR CLEANER
CANISTER TYPE AIR CLEANER
Air cleaner element is accessible by unsnapping two
clips on air canister and removing cover and air filter ele-
ment (Ref. Fig. 29 on page 20).
Clean inside of cover and canister.
Install element and cover the same way they were
removed. Be sure positioning arrow on cover is pointing
up and all clips are fastened securely.
CLEANING AIR FILTER ELEMENT
Do not use compressed air to clean air
filter; doing so will damage filter which
may result in damage to engine.
If element is in acceptable condition, loose dirt may be
removed by tapping filter lightly. Do not use oil on filter
element or any part of unit.
FUEL FILTER
To reduce possibility of
a n e x p l o s i o n , d o n o t
smoke near fuel tank or
in an area where gasoline is being handled. Do not
perform procedures involving fuel system near open
fire or electrical items which could produce a spark.
Do not handle gasoline in an area that is not ade-
quately ventilated.
Always wear safety glasses to prevent possible eye
injury from gasoline or gasoline vapor.
Fuel filter is located at front of engine above fan cover
(Ref. Fig. 30 on page 21).
Inspect it for dirt and/or water. Replace if significant
amount is found.
To replace, use a pair of pliers to move clamps off ends
of filter.
Remove hose coming from fuel tank first and plug.
Remove filter from hose going to fuel pump and discard.
Orient direction of new fuel filter according to
FLOW arrow on side of filter.
Install new fuel filter and reposition clamps over inlet and
outlet.
Fig. 28 Adjusting Alternator Belt
Ref Abt 3
3/8" (1 cm) Max. Deflection for New Belt
1/2" (1.3 cm) Max. Deflection for Existing
Belt
Fig. 29 Air Cleaner
Air Cleaner
Cover
Air Cleaner
Canister
Air Filter
Element
Ref Air 4
Clip
! !