E-Z-GO 602080 - Manual (Page 39)

OPERATION AND SERVICE INFORMATION
Page 23 Owner’s Manual and Service Guide
Read all of manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notes, Cautions and Warnings
tem. Do not use pressure in excess of 700 psi (4800 kPa)
to wash exterior of vehicle.
Clean windshield with lots of water and a clean cloth.
Normal cleaning of vinyl seats and plastic or rubber trim
requires use of a mild soap solution applied with a
sponge or soft brush and wipe with a damp cloth.
Removal of oil, tar, asphalt, shoe polish, etc. will require
use of a commercially available vinyl/rubber cleaner.
Painted surfaces require frequent washing with luke-
warm or cold water and mild detergent.
Occasional cleaning and waxing with non-abrasive prod-
ucts designed for ‘clear coat’ automotive finishes will
enhance the appearance and durability of the painted
surfaces.
Corrosive materials used as fertilizers or for dust control
can collect on underbody of vehicle. These materials will
cause corrosion of underbody parts unless flushed occa-
sionally with plain water. Thoroughly clean any areas
where mud or other debris can collect. Sediment packed
in closed areas should be loosened to ease it’s removal,
taking care not to chip or otherwise damage paint.
If engine does not start or runs improperly after
washing, remove spark plug wires (by pulling
the spark plug boots, never the wires). Dry all connections with
forced air. Reinstall wires.
CARE PRODUCTS
To help maintain the vehicle there are several products
available through local Distributors, authorized
Branches, or the Service Parts Department.
• Touch-up paint specially formulated to match vehi-
cle colors for use on both metal and molded plas-
tic bodies. (P/N 28140-G** and 28432-G** for
solid colors; 75831-G** for camouflage colors)
• Battery Protectant formulated to form a long-term,
flexible, non-tacky, dry coating that will not crack,
peel or flake over a wide temperature range. (P/N
75500-G01)
• White Lithium Grease designed to provide lubrica-
tion protection in areas where staining or discolor-
ing is a problem, or in areas of extreme
temperature ranges. (P/N 75502-G01)
• Penetrant/Lubricant, a 4-in-1 product that pene-
trates seized parts, lubricates leaving a light lubri-
cating film, reduces corrosion by adhering to wet
or dry surfaces and displaces moisture, sealing
against future moisture return. (P/N 75503-G01)
• Multi-purpose Cleaner and Degreaser that con-
tains natural, environmentally safe solvents. (P/N
75504-G01)
• Multi-purpose Hand Cleaner is an industrial
strength cleaner containing no harsh solvents, yet
gently lifts grease off hands. May be used with or
without water. (P/N 75505-G01)
• Battery Cleaner that neutralizes battery acids and
dissolves terminal corrosion and can be rinsed
with water. (P/N 75506-G01)
• Biodegradable Cleaner that breaks down grease
to be easily wiped or rinsed away. (P/N 75507-
G01)
• Multi-purpose Value Pack sampler includes 4
ounce (118 ml) aerosol cans of Battery Protector,
Penetrant/Lubricant, White Lithium Grease, and
Carburetor and Choke Cleaner. (P/N 75508-G01)
LABELS AND PICTOGRAMS
Vehicles are labeled with pictograms as a method of con-
veying information or warnings. Appendix A illustrates
and explains pictograms that appear on vehicle. Not all
pictograms shown in Appendix A will be used on vehicle.
Fig. 33 Jump Starting
Ref Jmp 1
+
-
+
-
Strong
Battery
Weak
Battery
Front of
Vehicle