Pentair MT User Manual
Page 2
Page 2
Pentair Water Commercial Pool and Spa
TABLE OF CONTENTS
SECTION 1.
General Information
1A.
Introduction ................................................... 3
SECTION 2.
Installation
2A.
Boiler Placement .......................................... 3
2B.
Installation of Indoor Boilers ......................... 4
2B-1.
Combustion Air Supply ................................. 4
2B-2.
Venting ......................................................... 5
2C.
Installation of Outdoor Water Units ............... 5
2D.
Freeze Protection ......................................... 6
2E.
Gas Supply and Piping ................................. 6
2F.
Electrical Wiring ............................................ 7
2G.
Piping of System to Boiler ............................ 7
2H.
General Water Piping ................................... 7
2I.
Boiler By-Pass Piping ................................... 8
2J.
Automatic Chlorinators ................................. 8
2K.
Pressure Switch ........................................... 8
SECTION 3.
Operation
3A.
Initial Start Up ............................................... 9
3A-1.
Initial Filter Cycle on a New Pool .................. 9
3A-2.
Starting Instructions ...................................... 9
3A-3.
Hi-Limit Checkout ....................................... 10
3B.
To Start Up System
(See Section 3A for Initial Start Up) ............ 10
3C.
To Turn Off Boiler ....................................... 10
3D.
Spring and Fall Operation ............................ 10
3E.
Winter Operation ......................................... 10
3E-1.
Draining Boiler Before Freezing ................... 10
3E-2.
Improper Use of the Boiler ........................... 10
3F.
Time Clock Operation .................................. 11
3G.
Spa (Hot Tub) Safety Rules ......................... 11
3H.
Periodic Service .......................................... 11
3I.
Pool Water Chemistry ................................. 11
SECTION 4.
Maintenance
................................................................... 12
SECTION 5.
Troubleshooting and Analysis of
Service Problems
................................................................... 12
SECTION 6.
Conversion of Model MT Pool Boilers
From Indoor to Outdoor Models
6A.
SECTION I ................................................. 14
6B.
SECTION II ................................................ 14
SECTION 7.
Parts Description and
Order Numbers
................................................................... 16
Pentair Technical Support
Sanford, North Carolina (8 A.M. to 5 P.M.)
Phone: (800) 831-7133
Fax: (919) 566-8920
Moorpark, California (8 A.M. to 5 P.M.)
Phone: (800) 831-7133
Fax: (800) 284-4151
Web sites:
visit www.pentairpool.com and www.staritepool.com