North Star 8000 IPG - Manual (Page 23)

Operation (cont’d)
23
2. Preparing for Operation
Position
generator Position generator in accordance with the instructions given in “Installation
& Initial Set-up, Step 4: Select a Suitable Site” of this manual.
Operate outside only, on dry, level ground with adequate clearance and
ventilation.
WARNING: Carbon monoxide poisoning hazard
Generators give off carbon monoxide exhaust, a poisonous gas that can
kill. You CANNOT smell it, see it, or taste it. ONLY run generator
OUTDOORS and away from air intakes. NEVER run generator inside
any enclosed or semi-enclosed spaces, including homes, garages,
basements, sheds, boxes, pick-up truck beds, RVs, or boats. These spaces
can trap poisonous gases, EVEN if you run a fan or open windows.
Carbon monoxide exhaust is given off whether you are using gasoline,
natural gas, or propane to power the generator.
Ground
generator Make sure the generator is grounded in accordance with instruction given
in “Installation & Initial Set-up, Step 5: Grounding the Generator” of this
manual.
WARNING: Electric shock hazard
Always ensure generator is properly grounded to prevent electrical
shock.
Perform
scheduled
maintenance as
needed Make sure that any regular maintenance has been performed as prescribed
in this manual in the “Maintenance & Repair”
section.
1. Refer to the engine owner’s manual for engine maintenance instructions.
2. Make sure battery is charged. Charge as needed according to your battery
manufacturer’s instructions.
Check/add oil Check the oil level using the dipstick and add oil as needed.
Using a funnel, add oil up to the FULL mark on the dipstick with the
recommended oil type for your engine and expected ambient conditions.
(See engine Owner’s Manual for oil type and capacity, and more detailed oil
check/fill instructions.)
WARNING: Burn hazard
Never open oil port while engine is running. Hot oil can spray over
face and body.
Notes:
o
Low oil shutdown feature prevents the generator from starting without
sufficient oil.
o Engine is shipped without oil. You must add oil before first use.
IMPORTANT:
Under long, continuous-run operating conditions, be prepared to:
• Check engine oil level every time you refuel the engine.
• Change oil after the first 20 operating hours, and at least every 100
operating hours thereafter, or as directed in engine owner’s manual.
Check/fill
gasoline tank Check the gasoline level in the generator’s tank. If needed, fill tank with
fresh unleaded gasoline from a portable container, after first reading the
warnings and instructions below.