Minuteman X Ride 28 Riding Extractor - Manual (Page 48)

48
Troubleshooting
8 Troubleshooting
Problem Possible Cause Remedy
Poor water pick-up / poor brush
performance Recovery tank full Empty recovery tank
Recovery tank drain hose leak Secure drain hose cap or replace
Recovery tank lid gasket leak Replace gasket lid cover properly
Debris caught in vacuum shoe Clean vacuum shoe
Vacuum hose clogged Remove debris and flush hose
Vacuum hose to vacuum shoe or recov-
ery tank disconnected to vacuum shoe
or damaged Reconnect or replace vacuum shoe
hose
Worn brushes Rotate or replace brushes
Wrong brush or cleaning chemical Consult Minuteman
Debris caught on scrub brushes Remove debris
Moving machine too fast Slow down
Low battery charge Recharge batteries
Debris box full Empty and clean debris box
Brushes worn Replace brushes
Bristles have taken a set Rotate brushes
No solution to off-aisle wand spray jet Solution tank empty Refill solution tank
No FWD/REV drive Drive system speed controller. Check error fault codes