Minuteman E 26 (7061.11) - Manual (Page 6)

4
Table of Content
Introduction . . . . . . . . . . . . . 2
Preface . . . . . . . . . . . . . . . . . . 2
Proper use . . . . . . . . . . . . . . . 2
Notes on warranty . . . . . . . . . 3
Acceptance of the machine . . 3
1 Safety information . . . . . . . . 5
1.1 Safety and Warning Symbols . 5
1.2 General Provisions . . . . . . . . . 6
1.3 Provisions for Operation. . . . . 6
1.4 Maintenance instructions . . . . 7
1.5 Specific Hazards . . . . . . . . . . 8
1.6 Information for Protection of
Environment . . . . . . . . . . . . . . 8
1.7 Labels at the Machine . . . . . . 9
2 First Operation . . . . . . . . . . 10
2.1 Instruction. . . . . . . . . . . . . . . 10
2.2 Initial charging procedure . . . 10
2.3 Before Taking into Operation 10
2.4 Start Machine . . . . . . . . . . . . 10
2.5 Operation . . . . . . . . . . . . . . . 11
2.6 Stop Machine . . . . . . . . . . . . 11
2.7 After Work . . . . . . . . . . . . . . 11
3 Operation . . . . . . . . . . . . . . 12
3.1 Method of Operation . . . . . . 12
3.1.1 Brush Deck. . . . . . . . . . . . . . 12
3.1.2 Solution Tank . . . . . . . . . . . . 12
3.1.3 Squeegee. . . . . . . . . . . . . . . 13
3.1.4 Recovery Tank . . . . . . . . . . . 13
3.1.5 Traction Drive. . . . . . . . . . . . 13
3.1.6 Batteries and Charger . . . . . 13
3.1.7 Options. . . . . . . . . . . . . . . . . 13
3.2 Operating and Indicating
Elements . . . . . . . . . . . . . . . 14
3.2.1 Operating Panel . . . . . . . . . . 14
3.2.2 At the Machine . . . . . . . . . . . 16
4 Technical Data . . . . . . . . . . 18
5 Maintenance and Care . . . . 20
5.1 Minuteman System Mainte-
nance . . . . . . . . . . . . . . . . . . 20
5.2 Maintenance Document . . . . 21
5.3 Maintenance Schedule. . . . . 22
5.4 Battery Systems . . . . . . . . . . 26
5.4.1 Charge Batteries . . . . . . . . . 27
5.4.2 Low Discharge Signal sender
(LDS) . . . . . . . . . . . . . . . . . . 27
5.4.3 Maintenance of Drive
Batteries . . . . . . . . . . . . . . . . 27
5.4.4 Remove Batteries. . . . . . . . . 27
5.4.5
Install Batteries. . . . . . . . . . . 27
5.4.6 Disposal of Batteries . . . . . . 27
5.5 Solution Tank . . . . . . . . . . . . 28
5.5.1 Fill Solution Tank . . . . . . . . . 29
5.5.2 Empty Solution Tank . . . . . . 29
5.5.3 Clean Solution Filter. . . . . . . 29
5.6 Recovery Tank . . . . . . . . . . . 30
5.6.1 Empty Recovery Tank . . . . . 31
5.6.2 Clean Recovery Tank. . . . . . 31
5.6.3 Clean Suction Filter . . . . . . . 31
5.7 Disc Brush Deck. . . . . . . . . . 32
5.7.1 Clean Brushes . . . . . . . . . . . 32
5.7.2 Change Brushes . . . . . . . . . 32
5.7.3 Change Roller Bumper. . . . . 32
5.7.4 Change Sealing Strip . . . . . . 32
5.8 Squeegee. . . . . . . . . . . . . . . 33
5.8.1 Clean Squeegee . . . . . . . . . 33
5.8.2 Change Squeegee Blades . . 33
5.8.3 Adjust Squeegee Blades . . . 34
Minuteman Limited
Warranty . . . . . . . . . . . . . . . 37