Fulton Pulse DWH (PDWH) Domestic Water Heater - Manual (Page 47)

43-PDWH
Warranty
Standard Warranty for Fulton Pulse Domestic Boilers
Warranty Valid for Models PDWH
Ten (10) Year Thermal Shock Warranty
Fulton Heating Solutions guarantees the Pulse hot water pressure vessel against thermal shock for a period of ten (10) years
when the boiler is installed and is operated per the Installation and Operation Manual. This guarantee will cover damage due to
thermal shock, such as leaks in the heat exchanger. This guarantee does not cover damage due to corrosion, scaling, sooting or
improper installation or operation. The inlet and outlet water temperature differential across the boiler cannot exceed 100 F.
Five (5) Year (60 Month) Material and Workmanship Warranty
The pressure vessel is covered against defective material or workmanship for a period of five (5) years from the date of shipment
from the factory. Fulton will repair or replace F.O.B. factory any part of the equipment, as defined above, provided this equipment
has been installed, operated and maintained by the buyer in accordance with approved practices and recommendations made by
Fulton. The commissioning agency must also successfully complete and return the equipment Installation and Operation
Checklists to Fulton’s Quality Assurance department. This warranty covers any failure caused defective material or workmanship;
however, waterside corrosion or scaling is not covered. Therefore, it is imperative that the boiler be installed as outlined in the
Installation and Operation Manual.
Five (5) Year (60 Month) Prorated Flue Gas Condensation Corrosion Warranty
The pressure vessel, combustor and exhaust pipes are covered against corrosion form flue gas condensation for a period of five
(5) years according to the schedule below. This warranty covers nay failure caused by flue gas corrosion, however, water-side
corrosion, scaling, or excessive cycling is not covered.
Year Prorated Schedule
0-3 100%
4 70%
5 40%
Parts Warranty
)XOWRQZLOOUHSDLURUUHSODFH)2%IDFWRU\DQ\SDUWRIWKHHTXLSPHQWRIRXUPDQXIDFWXUHWKDWLVIRXQGWREHGHIHFWLYHLQZRUNPDQVKLS
RUPDWHULDOZLWKLQPRQWKVRIVKLSPHQWIURPWKHIDFWRU\RUPRQWKVIURPVWDUWXS ZKLFKHYHUFRPHVILUVW SURYLGHGWKH
HTXLSPHQWKDVEHHQLQVWDOOHGRSHUDWHGDQGPDLQWDLQHGE\WKHEX\HULQDFFRUGDQFHZLWKDSSURYHGSUDFWLFHVDQGUHFRPPHQGDWLRQV
PDGHE\ERWK)XOWRQDQGWKHFRPSRQHQWPDQXIDFWXUHUVDQGWKHFRPPLVVLRQLQJDJHQF\KDVVXFFHVVIXOO\FRPSOHWHGDQGUHWXUQHG
WKHHTXLSPHQW,QVWDOODWLRQDQG2SHUDWLRQ&KHFNOLVWVWR)XOWRQ¶V4XDOLW\$VVXUDQFH'HSDUWPHQW
General
Fulton shall be notified in writing as soon as any defect becomes apparent. This warranty does not include freight, handling or
labor charges of any kind.
These warranties are contingent upon the proper sizing, installation, operation and maintenance of the boiler and peripheral
components and equipment. Warranties valid only if installed, operated, and maintained as outlined in the Fulton Installation and
Operation Manual.
No Sales Manager or other representative of Fulton other than the Quality Manager or an officer of the company has warranty
authority. Fulton will not pay any charges unless they were pre-approved, in writing, by the Fulton Quality Manager.
This warranty is exclusive and in lieu of all other warranties, expressed or implied, including but not limited to the implied
warranties of merchantability and fitness for a particular purpose. Fulton shall in no event be liable for any consequential or
incidental damages arising in any way, including but not limited to any loss of profits or business, even if the Fulton Companies
has been advised of the possibility of such damages. Fulton’s liability shall never exceed the amount paid for the original
equipment found to be defective.
Excessive cycling will reduce the life of ANY boiler. Verify that your system is properly designed and check cycling rate according
to maintenance procedures listed in this manual.
To activate the warranty for this product, the appropriate commissioning sheets must be completed and returned to the Fulton
Quality Assurance department for review and approval.
6/17/2011