American Power Conversion XR - Manual (Page 38)

Operation – Battery Replacement
30 Smart-UPS® VT 10-30 kVA, 208/220 V and XR Battery Enclosure Operation Manual 990-1599B
Battery Module removal
Follow the below procedures if you need to change or add a Battery Module, e.g. if you receive a
display message reporting a bad battery, or if you need to add batteries for increased runtime:
 When removing Battery Modules, start from the highest level and work down.
 Holding the battery handle, gently push the battery unit upwards and pull it halfway out of the
Enclosure. A lock mechanism prevents it from being pulled all the way out.
 To release the battery from the lock mechanism, one person gently pushes the battery upwards
again and pulls it out, while the other person supports the battery.
How to install a Battery Module
If additional batteries are needed for extra run-time, or if you install battery replacement modules
etc., follow the below procedure:
Two people to lift components weighing between 40 - 70 lbs / 18 - 32 kg.
10/100Base-T Probe
AP9619 Network Management Card EM
!
Reset
Output Pwr Zone
10/100
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT Model: Serial: BATTERY UNIT
Model: Serial: BATTERY UNIT



UPS XR
CAUTION!
Wait until you are ready to power up the system before installing Battery Modules in the
UPS. Failure to do so can result in a deep discharge of the batteries and cause permanent
damage (the time from the battery installation time till the UPS is powered up should
not exceed 72 hours or 3 days).