Karcher KM 75-40 W Bp Pack - Manual (Page 16)

- 5
Fault display:
 Open the device hood.
 Insert the charging cable of the charger
in the charger box of the sweeper
 Plug in mains connector and switch on
charger.
 KM 75/40 W Bp Pack
 Disconnect the mains plug.
 Wrap the mains cord around the cable
holder of the charger.
 Close cover.
 KM 75/40 W Bp
 Switch off the charger and remove the
plug from the socket.
 Hang out the charging cable out of the
machine.
 Close cover.
 Open the device hood.
 Disconnect pole terminal to negative
pole (-).
 Unscrew the connection wires from the
batteries.
 Disconnect pole terminal to positive
pole (-).
 Loosen the holding strap.
 Remove the battery.
 Dispose of the used battery according
to the local provisions.
Batteries and chargers are available in spe-
cialised stores.
Always use 2 batteries of the same type!
ƽ DANGER
Risk of injury! Switch off the appliance prior
to removing the waste container.
Note: Start the appliance only when the
hood is closed.

Park the sweeper on an even surface.
 Switch off engine.
 Lock parking brake.
 Check charging status of battery.
 Check side brush.
 Check roller brush.
 Shake off dust filter.
 Empty waste container.
Note: For description, see section on Care
and maintenance.
 Release parking brake.
Start the motor.

Turn the main switch to position “1”.
Note: The roller brush and the side brush
will rotate.
 Pull the lever for forward drive.
Note: The drive speed for forward drive
can be adjusted steplessly depending on
the position of the lever.
 Release the lever for forward drive. De-
vice comes to a halt.
Driving over fixed obstacles which are 30
mm high or less:

Raise bulk waste flap.
 Drive forwards slowly and carefully.
Driving over fixed obstacles which are
more than 30 mm high:

Only drive over these obstacles using a
suitable ramp.
ƽ Danger
Risk of injury! If the bulk waste flap is open,
stones or gravel may be flung forwards by
the roller brush. Make sure that this does
not endanger persons, animals or objects.
CAUTION
Do not sweep up packing strips, wire or
similar objects as this may damage the
sweeping mechanism.
Note: To achieve an optimum cleaning re-
sult, the driving speed should be adjusted
to take specific situations into account.
Note: To sweep up larger items up to a
height of 50 mm, e.g. cigarette packs, the
bulk waste flap must be raised briefly.
Raising bulk waste flap:

Pull the lever for raising the bulk waste
flap.
Lowering the bulk waste flap:

Release the lever for raising the bulk
waste flap.
Note: An optimum cleaning result can only
be achieved if the bulk waste flap has been
lowered completely.
 Move the lever to lower the side brush
to the front. The side brush will be low-
ered.
Note: During operation, the waste contain-
er should be emptied at regular intervals.
Note: During operation, the dust filter
should be shaken off and cleaned at regu-
lar intervals.
 Close wet/dry flap
 Open wet/dry flap.
Note: This protects the filter from moisture.
The battery display shows the charging sta-
tus of the batteries during operation:
 Pull the handle of the filter clean-off out
several times and reinsert it.
ƽ DANGER
Risk of injury! Switch off the appliance prior
to removing the waste container.
Note: Make sure the seal strip is not dam-
aged while emptying the waste container.
Note: The max. load of the waste container
is 40 kg.

Shake off dust filter.
 Pull lock bow of the waste container up-
ward.
 Pull out the waste container.
 Empty waste container.
 Push in the waste container.
 Push lock bow of the waste container
downward.
Switch off engine.

Turn the main switch to position “0”.
 The side-brushes lift up.
 Lock parking brake.
 Turn the main switch using "0" position
and pull it out.
Charger or motor control
malfunction glows red
Charging process - KM 75/40 W Bp
After charging
Remove the battery
Recommended batteries, chargers
Order number
Battery 60 Ah 6.654-226.0
Charger 6.654-225.0
Maximum battery dimensions
Length Width Height
267 mm 177 mm 190 mm
Start up
General notes
Inspection and maintenance work
Operation
Starting the machine
Drive the machine
Drive forward
Dry run
Driving over obstacles
Sweeping mode
Sweeping with bulk waste flap raised
Sweeping with side brushes
Sweeping dry floors
Sweeping damp or wet floors
Battery display
full glows green
30% capacity remaining glows yellow
10% capacity remaining blinks red
Protection against total
discharge; the appliance
is switched off
glows red
Cleaning the dust filter
Emptying waste container
Turn off the appliance
16 EN