Power Soak 37179 PS-275 Service Manual - Manual (Page 5)

8.3a Disassembly ......................................................................................... 36
8.3b Inspection ............................................................................................. 36
8.3c Assembly .............................................................................................. 36
8.4 Chemical Dispenser (Optional) .............................................................. 36
Troubleshooting - Section 9 ....................................... 37
9.1 The pump will not start when the green “START” button is pushed. ...... 38
9.1a. Control panel white POWER light is not on. ........................................ 38
9.1b. Control panel white POWER light is on. .............................................. 38
9.1c. Control panel POWER (white) light is on, STATUS (green) light
is on and WASH TANK (blue) light is on. ............................................ 38
9.1d. Control panel POWER (white) light is on, STATUS (green) light
is on and SANATIZER TANK (red) light is on. .................................... 38
9.1d. Control panel STATUS light and ERROR are blinking with a
pattern of long and short flashes. ........................................................ 39
9.1e. All of the lights on the control panel and all of the Alert Lights
are flashing. ......................................................................................... 39
9.2 Motor starts, but makes noise. ............................................................... 39
9.3 Motor starts, but no water flows in the wash tank. .................................. 40
9.4 The control circuit fuse “blows” when the power is turned on. ................ 40
9.5 The lights indicate that the tank is empty when it is actually full. ............ 40
9.6 The water gets too hot and stops the machine. ...................................... 41
9.7 The chemical dispenser pump runs, but does not pump the chemical. .. 41
Parts Lists – Section 10 ............................................. 42
10.1 Motor and Pump Assembly .................................................................. 43
10.1a Parts list .............................................................................................. 43
10.1b 60 Hz Motor and Impeller ................................................................... 44
10.1c 50 Hz Motor and Impeller .................................................................... 44
10.1d Pump Parts Common to all Assemblies.............................................. 44
10.1e Seal Kit ............................................................................................... 44
10.2 Heater & Sensor Block ......................................................................... 45
10.3 Control Panel ....................................................................................... 46
10.4 Decal Locations and Part Numbers. ..................................................... 47
10.4a Unit with Left to Right Work Flow ........................................................ 47
10.4b Unit with Right to Left Work Flow ........................................................ 47
Appendix ................................................................... 49
Other PS-275 Manuals and Related Component Manuals .......................... 50
Wiring Diagrams ........................................................................................... 50
Electric Wiring Diagram – Single Phase ....................................................... 51
Electric Wiring Diagram – 3 Phase ............................................................... 52
AWI Insert Diagram ...................................................................................... 53