NaceCare Solutions RM1800F User Manual
Page 3
3
Safety instructions (CONT’D)
• Do not bring the end of the suction hose or one of the accessories near yours or others’ face,
particularly near ears and eyes: the sucked air could seriously damage them.
• If the machine is used as a wet vacuum cleaner, you must check the water level in the recovery
tank regularly to avoid water being sucked in by the vacuum motor.
• Avoid vacuuming a large quantity of foam. The foam may be sucked into the vacuum motor and
damage it. Follow steps from paragraph “Working method”.
• In case of abnormal function (very noisy motor, pump not on, extreme temperature rise, etc.)
switch the machine OFF and pull out the plug.
After use, clean the machine and store it in a dry and closed place.
Construction of the machine
The FoamTec 1800 is comprised of the following parts:
•
The lower tank contains the clean water
•
The upper tank is the recovery tank
•
The discharge for the recovery tank is at the rear of the machine
•
The pumps and vacuum motor are situated inside the lower tank
•
The air compressor is located in the box underneath the bottom tank.
•
The control panel located on the upper tank houses all of the switches for the pump,
vacuum motor, and air compressor.
•
Attached to the lower tank is a tray for the one gallon foaming chemical and the anti-
foam chemical.
•
The vacuum hose plugs in to the rear of the recovery tank. Attached to the cuff of the
vacuum hose is the defoamer line. The defoamer is dispensed automatically while
using the vacuum.
•
The blower outlet is located on the right side of the solution tank.
•
The air compressor is located inside the box situated inside the metal casing at the
bottom of the machine
Accessories included
• 33 foot wire reinforced vacuum hose 1 ½ inch
• 6 foot stretch blower hose 1 ¼ inch, that expands up to 30 feet, c/w blower nozzle
• Single piece double “S” bend floor wand c/w hard floor squeegee tool and handle hook
• 50 foot spray / rinse hose
• High / low pressure spray gun
• Window
/
mirror
squeegee
• Hard floor brush and handle