Installation – InnoMax Scape Adjustable Power Base User Manual
Page 9
PowerBASE Owners Manual
INSTALLATION
10. Install mattress retainer as follows:
a. Install (1) cupped washer, (1) spacer
and (1) flat washer on (4) mattress
retainer bolts (
FIGURE 4).
b. Install the mattress retainer bolts (loosely)
into tapped holes in the foot section of the
bed base frame (
FIGURE 5).
c. Slide each U-shaped end of the
mattress retainer around the mattress
retainer bolts. Position the retainer
ends between the spacer and the
washer (
FIGURE 5).
d. Tighten screws to complete mattress
retainer installation (
FIGURE 6).
Note: it is important to position the
bottom of the headboard cross member
a maximum distance of 3 inches
(76.2mm) between the headboard and
the top of the mattress (FIGURE 7). Do
not exceed 3 inches (76.2mm).
FAILURE TO FOLLOW HEADBOARD
BRACKET INSTALLATION INSTRUCTIONS
MAY CAUSE HEADBOARD BRACKET
INTERFERENCE WITH BASE FOAM DURING
ADJUSTABLE BED OPERATION. BASE
FOAM OR BASE COVER DAMAGE COULD
RESULT.
NOTE
Note: if adjustable bed is to be set up
without a headboard, install mattress on
the bed base frame and installation is
complete. If headboard is to be installed,
proceed per step 8 below.
11. Install headboard brackets to the bed base
frame. When attaching (2) twin size units
to a king size headboard, use a swing
hinge kit (see accessory sheet) to connect
the twin units.
FIGURE 6: Typical mattress retainer installed.
MATTRESS RETAINER HARDWARE
KIT CONTAINS:
(4) MATTRESS RETAINER BOLTS - A
(4) FLAT WASHERS - B
(4) SPACERS - C
(4) CUPPED WASHERS - D
CUPPED
WASHER
FLAT
WASHER
SPACER
MATTRESS
RETAINER
BOLT
ASSEMBLE AS
SHOWN BELOW:
A
B
C
D
FIGURE 4: Mattress retainer hardware.
FLAT WASHERS FIT
BETWEEN THE BED
BASE FRAME AND THE
MATTRESS RETAINER
(2) TAPPED HOLES IN
EACH SIDE OF THE
BED FOOT SECTION
MATTRESS
RETAINER
FIGURE 5: Mattress retainer installation
7
DO NOT USE POWER SCREWDRIVER TO
INSTALL MATTRESS RETAINER.
DO NO
DO NO
DO NO
DO NO
DO NOTTTTT
O
O
O
O
OVERTIGHTEN MA
VERTIGHTEN MA
VERTIGHTEN MA
VERTIGHTEN MA
VERTIGHTEN MATTRESS RET
TTRESS RET
TTRESS RET
TTRESS RET
TTRESS RETAINER
AINER
AINER
AINER
AINER
HARD
HARD
HARD
HARD
HARDW
W
W
W
WARE!
ARE!
ARE!
ARE!
ARE!
NOTE