Snorkel TB37 2001 - Manual (Page 13)

The aerial platform can tip over if it becomes unstable.
Death or serious injury can result from a tip-over acci-
dent. Do not drive or position the aerial platform for ele-
vated use near any drop-off, hole, slope, soft or uneven
ground, or other tip-over hazard.
All platform occupants must wear a fall restraint device con-
nected to a lanyard anchor point.
It is best not to transfer from the platform to another struc-
ture or from the structure to the platform, unless that is the
safest way to do the job. Judge each situation separately
taking the work environment into account.If it is necessary
to transfer from the platform to another structure the fol-
lowing guidelines apply:
1. Where possible, place the platform over a roof or
walking structure to do the transfer.
2. Transfer your anchorage from one structure to the
other before stepping across.
3. Remember that you might be transferring to a struc-
ture where personal fall arrest is required.
4. Use the platform entrance, do not climb over the
guardrails.
Do not operate the aerial platform in windy or gusty con-
ditions. Do not add anything to the aerial platform that
will increase the wind loading such as billboards, ban-
ners, flags, etc.
Never operate the aerial platform without all parts of the
guardrail system in place and the gate closed. Make sure
that all protective guards, cowlings, and doors are se-
curely fastened.
Do not exceed the platform capacity as indicated on the
platform rating placard on the platform. Do not carry
loads that extend beyond the platform guardrails without
prior written consent from Snorkel.
Do not operate the aerial platform from trucks, trailers,
railway cars, floating vessels, scaffolds, or similar
equipment unless the application is approved in writing
by Snorkel.
Do not use the aerial platform as a crane, hoist, jack, or
for any purpose other than to position personnel, tools,
and materials.
Do not climb on the guardrails or use ladders, planks, or
other devices to extend or increase the work position
from the platform.
Take care to prevent rope, electrical cords, and hoses, etc.,
from becoming caught in or on the aerial platform. If the
platform or booms becomes caught on an adjacent struc-
ture or other obstacle and is prevented from normal motion,
reverse the control to free the platform. If control reversal
does not free the platform, evacuate the platform before at-
tempting to free it.
Electrical System
Charge the batteries in a well-ventilated area free of
flame, sparks, or other hazards that might cause fire or
explosion.
Do not operate any of the aerial platform functions while
the battery charger is plugged in.
Batteries give off hydrogen and oxygen that can
combine explosively. Death or serious injury can re-
sult from a chemical explosion. Do not smoke or
permit open flames or sparks when checking the
batteries.
Battery acid can damage the skin and eyes. Serious
infection or reaction can result if medical treatment
is not given immediately. Wear face and eye protec-
tion when working near the batteries.
Batteries contain sulfuric acid that can damage your
eyes or skin on contact. Wear a face shield, rubber
gloves, and protective clothing when working around
batteries. If acid contacts your eyes, flush immediately
with clear water and get medical attention. If acid con-
tacts your skin, wash off immediately with clear water.
Hydraulic System
The hydraulic system contains hoses with hydraulic
fluid under pressure.
Hydraulic fluid escaping under pressure can have
enough force to inject fluid into the flesh. Serious
infection or reaction can result if medical treatment
is not given immediately. In case of injury by escap-
ing hydraulic fluid, seek medical attention at once.
Do not place your hand or any part of your body in front
of escaping hydraulic fluid. Use a piece of cardboard or
wood to search for hydraulic leaks.
Engine and Fuel
Handling Precautions
Refer to the engine manufacturer’s Operator’s Manual
for complete information on safe engine operation,
maintenance, and specifications.
Engine exhaust contains carbon monoxide, a poi-
sonous gas that is invisible and odorless.
Breathing engine exhaust fumes can cause death
or serious illness. Do not run the engine in an en-
closed area or indoors without adequate ventila-
tion.
Operate dual fuel machines on LPG fuel when indoors
to reduce exhaust fumes and carbon monoxide.
Chapter 3. Safety
TB37 – 0172094 page 3 - 3
DANGER
DANGER
DANGER
DANGER