JLG 4009 Suspended Load Supplement Operator Manual User Manual
Page 7
Table of Contents
i
31200487
TABLE OF CONTENTS
Operator Qualifications ...................................................... b
Modifications ...................................................................... b
Other Publications Available .............................................. d
Section 1 - General Safety Practices
1.1 Hazard Classification System ..............................................1-1
Safety Alert System and Safety Signal Words ................1-1
1.2 General Precautions ............................................................1-1
1.3 Operation Safety ..................................................................1-2
Electrical Hazards ...........................................................1-2
Tip Over Hazard..............................................................1-3
Travel Hazard .................................................................1-6
Load Falling Hazard ........................................................1-7
Lifting Personnel .............................................................1-8
Driving Hazards on Slopes .............................................1-9
Pinch Points and Crush Hazards ..................................1-10
Fall Hazard....................................................................1-12
Chemical Hazards.........................................................1-13
Section 2 - Load Management Indicator System (LMIS)
2.1 General ................................................................................2-1
2.2 Control Panel .......................................................................2-2
Display ............................................................................2-3
2.3 Operation .............................................................................2-4
System Start Up ..............................................................2-4
Attachment Selection ......................................................2-5
Lifting Conditions and Alarms .........................................2-6
2.4 Diagnostic Data ...................................................................2-7
Alarms and Warnings......................................................2-7
LMI Values ......................................................................2-7
Pressure Values..............................................................2-8
Angle and Length Transducers .......................................2-8
LMI Status .......................................................................2-9
Table of Contents