JLG 80HX_HX+6 Operator Manual - Manual (Page 25)

SECTION 2 - PREPARATION AND INSPECTION
2-8 – JLG Lift – 3120890
20. Control Valves (Tank Compartment) - No loose or
missing parts, no evidence of leakage, no damaged
wires.
21. Hydraulic Oil Supply - Recommended oil level in
sight gauge. (Check level with cold oil, systems shut
down, machine in stowed position) Cap in place
and secure.
22. Steer Cylinder Assembly - Properly secured, no
visible damage or signs of leakage.
23. Cowling and Latches, Right Side - All cowling and
latches in working condition, properly secured, no
loose or missing part.
24. Spindle, Right Front - Properly secured, no loose
or missing parts, no visible damage.
25. Drive Hub, Right Front - No visible damage, no evi-
dence of leakage. (4 Wheel Drive)
26. Wheel/Tire Assembly, Right Front - Properly
secured, no loose or missing lug nuts, no visible
damage.
27. Tie Rod and Steering Linkage, Right Front - No
loose or missing parts, no visible damage. Tie rod
end studs locked.
28. Axle Lock Pin, Right Front - No loose or missing
parts, no visible damage. Installed in proper loca-
tion.
29. Oscillating Axle Cylinder, Right Front - Properly
secured, no visible damage or signs of leakage. (If
Equipped)
30. Ground Controls - Switches operable, no visible
damage, decals secure and legible.
31. Manual Descent - No evidence of leakage, no visi-
ble damage.
32. Oscillating Axle - Properly secured, no loose or
missing parts, no visible damage. (If Equipped)
33. Towing Package - No loose, damaged or missing
parts, no visible damage. (If Equipped)
34. Master Cylinder - Properly secured, evidence of
lubrication.
35. Lift Cylinder - Properly secured, evidence of lubri-
cation.
36. Oscillating Axle Cylinder, Left Front - Properly
secured, no visible damage or signs of leakage. (If
Equipped)
37. Axle Lock Pin, Left Front - No loose or missing
parts, no visible damage. Installed in proper loca-
tion.
38. Tie Rod and Steering Linkage, Left Front - No
loose or missing parts, no visible damage. Tie rod
end studs locked.
39. Auxiliary Power Pump - No loose or missing parts,
no evidence of leakage, no damaged wires.
40. Wheel/Tire Assembly, Left Front - Properly
secured, no loose or missing lug nuts, no visible
damage.
41. Spindle, Left Front - Properly secured, no loose or
missing parts, no visible damage.
42. Drive Hub, Right Front - No visible damage, no evi-
dence of leakage. (4 Wheel Drive)
43. Hydraulic Pump - No loose or missing parts, no evi-
dence of leakage.
44. Muffler and Exhaust System - Properly secured,
no evidence of leakage
45. Engine Oil Supply - Full mark on dipstick; filler cap
secure.
46. Cowling and Latches, Left Side - All cowling and
latches in working condition, properly secured, no
loose or missing part.
47. Engine Air Filter - No loose or missing parts; no vis-
ible damage; element clean.
48. Battery - Proper electrolyte levels; cables tight, no
visible damage or corrosion.
49. Turntable Lock - Operable; No missing parts, no
visible damage.
50. Wheel/Tire Assembly, Left Rear - Properly
secured, no loose or missing lug nuts, no visible
damage.
Figure 2-4. Daily Walk-Around Inspection - Sheet 3 of 4