Marshalltown 46E11 Cyclone Power Trowels - Manual (Page 12)

1A
OPERATIONS
1A-10
1.12 Periodic Maintenance Schedule
The chart below lists basic engine maintenance. Refer to engine manufacturer’s Operation Manual for additional information
on engine maintenance. A copy of the engine Operator’s Manual was supplied with the machine when it was shipped.
DAILY EVERY 50 EVERY 100 EVERY 300
HOURS HOURS HOURS
GREASE TROWEL ARMS X
CHECK OIL LEVEL IN GEARBOX X
CHECK FUEL FILTER X
INSPECT AIR FILTERS -
REPLACE AS NEEDED
X
CHECK AND TIGHTEN EXTERNAL HARDWARE X
CHECK AND ADJUST DRIVE BELTS X
CHANGE ENGINE OIL X
REPLACE FUEL FILTER X
REPLACE SPARK PLUG X
1.13 Trowel Gearbox
Check gearbox sight glass for correct oil level daily(every 8 hours). Add oil if oil level is below the bottom third of sight glass.
The gearbox oil level should only be checked when the gearbox is in the level position. To add oil, tilt trowel back and remove
sight glass. Add oil through sight glass opening. Replace sight glass and check oil level. Do
NOT fill past the 3/4 full point.
Use only special blend Marshalltown gear oil part# M048299.