Rockwell Automation Flex/WebPak 3000 Version 1.x Drive Regulator Board Installation, M/N 920WK0011 - Manual

Reliance and WebPak are trademarks of Rockwell Automation.
© 2000 Rockwell International Corporation
Regulator Board Installation Instructions
for WebPak 3000 Version 1.x Drives
M/N 920WK0011
Instruction Manual D2-3465
This manual provides instructions for replacing the Regulator board in your WebPak 3000™ drive with a
version 1.x Regulator board. It is intended for qualified electrical personnel. The Regulator board is sold
individually as P/N 179269.
The installation procedure consists of replacing the Regulator board and restoring your drive configuration.
Perform the instructions in the order in which they are presented in this manual. The board replacement
procedure is the same for all WebPak 3000 drives.
You will need to refer to WebPak 3000 drive instruction manuals as you perform the installation procedure.
These manuals are shipped with the WebPak 3000 drive. The current WebPak 3000
Software Reference
manual also ships with this kit.
Kit Contents
The WebPak 3000 Version 1.x Regulator Board kit (M/N 920WK0011) consists of the following:
Getting Assistance From Reliance Electric
If you have any questions or problems with the products described in this instruction manual, contact your local
Reliance Electric sales office. For technical assistance, call 1-800-726-8112.
!
ATTENTION: Only qualified personnel familiar with the construction and operation of this
equipment should install, adjust, operate, and/ or service this equipment. Read and understand
this instruction manual in its entirety before proceeding. Failure to observe this precaution could
result in severe bodily injury or loss of life.
ATTENTION: All interconnecting wiring must be sized and installed in conformance with
applicable local, national, and international codes. Failure to observe this precaution could result
in damage to, or destruction of, the equipment.
Part Number Description Quantity
179269 Regulator Board 1
179348 WebPakCS Software 1
D2-3444 WebPak 3000 Software Reference Manual 1
D2-3465 Regulator Board Installation Instructions for WebPak 3000 Version 1.x Drives 1