Watts IWTG-NYC - Manual

IWTG-NYC and IWTG-HTX
Installation Instructions
Note: Prior to using the IWTG-Gas Test Gauge
please read the installation instruction in their
entirety and observe warnings and cautions.
The IWTG-Gas Test Gauge is intended
to accurately measure low pressures and
detect the presence of leaks in natural gas
and liquefied petroleum piping.
The gauge is assembled to a
3 ⁄
4
" (8mm)
female NPT manifold. It is supplied with an
air valve and a shutoff valve.
Warning: Do not use pipe dope on the threads of the valve or manifold. Use of
pipe dope will void the warranty.
Installation to piping must be accomplished with Teflon tape only. Do not use pipe
dope. After installation of the IWTG-Gas pressurize the system per the applicable
local requirements.
Warning: Do not exceed the maximum pressure indicated on the gauge dial.
Damage due to over pressurization will void the warranty. The gas/air used to
pressurize the system must be dry and free of contaminants. On completion of
inspection and test, discharge air from the system using the air valve.
Caution: This precision instrument must be handled and stored with care.
Model IWTG-NYC
0 – 10psi (0.7 bar) ± 2% accuracy
2 1 ⁄
2
" (65mm) dial face
Model IWTG-NYC
0 – 5psi (0.3 bar) ± 2% accuracy
2 1 ⁄
2
" (65mm) dial face
Model IWTG-HTX
0 – 10psi (0.7 bar) ± 1% accuracy
4" (100mm) dial face with indicator hand
Model IWTG-HTX
0 – 5psi (0.3 bar) ± 1% accuracy
4" (100mm) dial face with indicator hand
IS-IWTG-GAS-HTX/NYC 0845 EDP# 1915922 © Watts, 2008
USA: 815 Chestnut St., No. Andover, MA 01845-6098; www.watts.com
Canada: 5435 North Service Rd., Burlington, ONT. L7L 5H7; www.wattscanada.ca
Water Safety & Flow Control Products
Limited Warranty: Watts Regulator Co. (the “Company”) warrants each product to be free from defects in material and
workmanship under normal usage for a period of one year from the date of original shipment. In the event of such defects
within the warranty period, the Company will, at its option, replace or recondition the product without charge.
THE WARRANTY SET FORTH HEREIN IS GIVEN EXPRESSLY AND IS THE ONLY WARRANTY GIVEN BY THE COMPANY
WITH RESPECT TO THE PRODUCT. THE COMPANY MAKES NO OTHER WARRANTIES, EXPRESS OR IMPLIED. THE
COMPANY HEREBY SPECIFICALLY DISCLAIMS ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, INCLUDING BUT NOT
LIMITED TO THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.
The remedy described in the first paragraph of this warranty shall constitute the sole and exclusive remedy for breach
of warranty, and the Company shall not be responsible for any incidental, special or consequential damages, including
without limitation, lost profits or the cost of repairing or replacing other property which is damaged if this product does not
work properly, other costs resulting from labor charges, delays, vandalism, negligence, fouling caused by foreign material,
damage from adverse water conditions, chemical, or any other circumstances over which the Company has no control.
This warranty shall be invalidated by any abuse, misuse, misapplication, improper installation or improper maintenance or
alteration of the product.
Some States do not allow limitations on how long an implied warranty lasts, and some States do not allow the exclusion
or limitation of incidental or consequential damages. Therefore the above limitations may not apply to you. This Limited
Warranty gives you specific legal rights, and you may have other rights that vary from State to State. You should consult
applicable state laws to determine your rights. SO FAR AS IS CONSISTENT WITH APPLICABLE STATE LAW, ANY IMPLIED
WARRANTIES THAT MAY NOT BE DISCLAIMED, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND
FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED IN DURATION TO ONE YEAR FROM THE DATE OF ORIGINAL
SHIPMENT.
IS-IWTG-GAS-HTX/NYC