Thetford 19289 - RV Water Saver - Manual

Made in U.S.A./Fabriqué aux É.-U./Hecho en EE.UU.
Parts/Pièces/Particulos
Thetford Corporation
Ann Arbor, MI 48106 • 1-800-521-3032 • www.thetford.com
Part No.
No de pièce
particulo No.
RV Toilets/cabinets permanents/inodoros
19289
Water Saver
Trousse pour économiseur d’eau
Juego del economizador de agua
Fig. 1 (Aurora only)
Fig. 2
(Aurora only)
Hinge Posts/Nuts
Tie-
Down
Strap
Fig. 3
Fig. 4
Installation Instructions
Tools Needed
• 1/2" Wrench • Channel Locks
• Flat-Head Screwdriver
• Knife, wire cutters or squeeze-type tubing cutters
• 13/16-inch, 12-pt. Socket
NOTE: Not all parts in package may be needed.
Toilet Removal (if necessary)
1. Turn off water supply to toilet (see vehicle Owner’s Manual).
2. At back of toilet, remove water line from Water Valve.
3. (Aurora) Remove Side Access Covers. (Style Plus) Remove
plastic shroud from around base.
4. Remove nuts holding toilet to floor.
5. Lift toilet from floor.
6. Remove old Closet Flange Seal.
Removing Existing Water Saver
1. (Aurora) Remove left side Hinge Post Nut (as viewed from back,
Fig. 1) to release Tie-Down Strap (Fig. 2). (A 13/16-inch socket
may be needed.)
2. Access vacuum breaker.
3. Loosen screw on old Clamp. Pull off hose. Remove and save
clamp. Discard old Water Saver (Fig. 4).
F# 33069
8/05
Installing New Water Saver
1. Access Hose Barb (Fig. 3).
2. If not already cut, use knife or wire cutters to cut between two
ribs on sealed end.
3. (Aurora only) Place Tie-Down Strap (Fig. 2) on Hand Spray
hose.
4. Place Clamp over spray hose and push spray hose up onto Hose
Barb. Tighten Clamp (Fig. 4).
5. (Aurora only) Push Vacuum Breaker back into toilet.
6. (Aurora only) Remove left Hinge Post Nut. Attach Tie-Down
Strap. Re-tighten Hinge Post Nut with 13/16-inch socket. Do not
overtighten (12 in.-lb. max.).
7. Install wall bracket in desired location (close to toilet).
Toilet Installation
1. Install new Closet Flange Seal in bottom of toilet with lip
oriented down. NOTE: use thicker lip seal for Aurora. For all oth-
ers, use seal with smaller lip.
2. Reinstall toilet, reversing “Toilet Removal” steps above.
3. Flush test. Check for leaks.
Cut
Here
Aurora
®
, Aria ® CLASSIC
, Aqua-Magic
®
STYLE
TM LITE
, STYLE
TM PLUS
Style
Lite
(Style
Plus
similar)
Cut
Here