PS Engineering PDA360EX Installation Manual - Manual (Page 41)

PS Engineering Inc. ®
PAR100EX Audio Selector Panel and Intercom System
Installation and Operator’s Manual
200-760-0000 Appendix D Rev. 12, Jan. 2014
Appendix D – J2 Connector Interconnect
20
31
16
1
35
36
24
23
25
4
3
2 Copilot Phones (R)
Copilot Phones (L)
Copilot Phones Lo
Pass. 1 Mic Jack
Pass. Mic Lo
Pass. Mic Hi
37
38
Pass. 2 Mic Jack
Pass. Mic Lo
Pass. Mic Hi
32
33
34 Copilot Mic Audio
Copilot PTT
Copilot Mic Lo
Copilot PTT
Copilot Mic Jack
14
13
Ent. #2 Mute
PAR100EX J2 CONNECTOR
(Sub-D 44-pin male on tray)
Ent. #2 Input
27
26
28 Ent. #2 Audio (R)
Ent. #2 Audio (L)
Ent. #2 Audio Lo
Notes:
Ent. #1 Audio (R)
Ent. #1 Audio (L)
Ent. #1 Audio Lo
Ent. #1 Input
5
6
7
Copilot PhonesJack
Pilot Phones (R)
Pilot Phones (L)
Pilot Phones Lo
Pilot PhonesJack
Backlighting
See Sect. 2.4.2
8
9
Ground Lug
Airframe Ground
29
17
Radio Power 44
Swap
Switch
Swap
10
11
43
1. All Power, and Ground wires must be #22 gage wire
Lighting #22 AW G, other wires minimum #24 AW G.
2. All shields should be grounded at audio panel only,
other end remains floating
3. Pins 8 and 9 connected through a 3 A breaker to aircraft power
for the audio panel.
Pin 44 is connected through a SEPARATE 3A breaker to aircraft
power for communication radio.
Breakers must be pull-type.
4. All shielded wires must be MIL 22750 or 27500.
5. For music distribution information, see Section 2.5.1.
6. Use care when connecting music signal and ground inputs.
Refer to section 2.4.1.1 for more information.
Failure to properly interface music can result in
added noise.
7. This system shipped configured for 24VDC.
See section 2.9 for 12V operation.
Unswitched Input #4 Hi
Unswitched Audio Lo
Unswitched Audio #4
15
40
7
6
5
12 V Lights Hi
12-Volt lights lo
3A Breaker
See Note 3, 7
Note 6
Backlighting
See Sect. 2.6.3
3A Breaker
See Note 3 & 7
RS232 TXD
RS232 RXD
Communications
Transceiver
(R760)
2
5
9
11 30
42 Radio Power
Radio Ground
Audio Panel Power
(Shipped for 24V)
Music 1 All headsets 22
CAUTION
T O PREVENT DAMAGE TO THE
M760REM, THE PAR100EX MUST
BE PROPERLY CONFIGURED FOR 12
OR 24 OR 24 VDC OPERATION .
PASS Music