Winco ULPSS8B2W/E - Manual (Page 15)

5 075-00 60706-2
MODULE DISPLAY
TIMER ICON
When the module is controlling the engine (start-
ing and stopping) an animated timer icon will be
displayed in the icon area to indicate that a timer is
active, for example cranking time, crank rest, etc.
STOPPED ICON
When there are no alarms present, an icon will be
displayed to indicate the engine is stopped and what
mode the unit is in.
Stop Mode Auto Mode Manual Mode
RUNNING ICON
When there are no alarms present, an animated icon
is displayed to indicate the engine is running.
USB ICON
When a USB connection is made to the module the
USB icon is displayed.
MEMORY CORRUPTION
If either the config file or engine file becomes cor-
rupted the unit will display the following icon.
SEE PAGE 18 FOR FAULT CODE ICONS
PREVENTIVE
MAINTENANCE
Reasonable care in preventive maintenance will
insure high reliability and a long life for the engine
generator set and Automatic Transfer Switch.
*****************
***** WARNING *****
*****************
When performing any type of maintenance on this
equipment make sure the selector switch on the en-
gine generator is in the off position. If you are work-
ing in the Automatic Transfer Switch, confirm with a
reliable meter that all power has been disconnected.
AUTOMATIC TRANSFER SWITCH
Clean and inspect the switch once a year. de-ener-
gize all power sources, both line and engine genera-
tor set, then brush and vacuum away any excessive
dust or dirty accumulation. You can at this time with
the contactor de-energized remove the contactor
covers and check the contacts. Make sure contacts
are clean and not burned or pitted.
ENGINE GENERATOR SET
Service the engine in accordance with the engine
manufacturers manual provided with your new
equipment. Routinely remove debris and dirt from
around the inside generator enclosure. Insure that
the air intakes are free from leaves and other debris
at all times.
Clean and inspect battery terminals a least twice a
year. Check the battery water level at least twice a
year also.
Other than keeping the generator clean and free of
debris there is no other routine or preventative main-
tenance required, as long as the generator is run
biweekly to keep it dry and in good working order.
COLD WEATHER OPERATION
Extreme cold weather operation requires special
considerations. Higher CCA batteries are required
for cold weather starting, 650 CCA or larger are rec-
ommended. In addition you should consider install-
ing an oil heater kit and a battery warmer for reliable
starting during cold weather.