Daktronics Galaxy AF-3500/3550 - Manual (Page 29)

Parts Replacement 25
Section 8: Parts Replacement
Important Notes: Disconnect power when servicing the display. Only qualified
service personnel should service internal electronic components.
8.1 About Replacement Parts
The following table contains some of the items that may need to be replaced
in a display over a period of time. These components are generally located
as shown in
Figure 10. If a component is not listed in the replacement parts
list, use the label to order a replacement. Most components within this display carry a label that lists the part
number of the unit. A typical label is shown in
Figure 21 with the part number in bold.
8.2 Instructions for Replacing Parts
Module Replacement
Tool Required: 1 /
8
” Hex Wrench
If LEDs have failed, do not attempt to replace
individual LEDs. Return a failed module to
Daktronics for replacement and/or repair.
Each module can be removed separately without
moving other components of the display.
1. Turn off power to the display.
2. Follow the instructions in Section 6.2
to release the module from the display
cabinet.
3. Disconnect the two ribbon cables from the
module, noting how they are connected
to the back. Release ribbon cables by
spreading the tabs on the sides and then
lifting the cable head from the jack.
4. Unplug the power cables by squeezing
the tabs on the sides of the plug head and
pulling out.
5. Connect all three cables to the new
module, making sure that the ribbon cable
tabs are tightly pushed against the cable
head. Carefully push the ribbon wires
back into the cabinet so they are clear of
the module edges.
6. Place the module into its proper location,
checking that the weather stripping is in
place. Latch the module tightly at both top
and bottom by turning the hex wrench a
quarter turn clockwise.
0P-1127-0024
SN: 2465
02/19/12 Rev. 1
Figure 21: Typical Parts Label
Part Description Part Number
Module; AF-3500 34 mm Amber 0A-1208-5009
Module; AF-3500 34 mm Red 0A-1208-5005
Module; AF-3550 34 mm RGB 0A-1208-5650
Module; AF-3500 20 mm Amber 0A-1266-5017
Module; AF-3500 20 mm Red 0A-1266-5005
Module; AF-3550 20 mm RGB 0A-1266-5650
Module; AF-3550 16 mm RGB 0A-1569-5551
M3 Controller III 0A-1382-0016
MLC 0P-1273-0067
Power Supply, 3-6.5V A-2307
Transformer T-1119
Transformer, International T-1121
RFI Filter Z-1007
Relay K-1040
Temperature Sensor 0A-1151-0011
Thermostat 0A-1327-3103
Light Level Detector 0P-1151-0002
Light Sensor Assembly 0A-1327-3000
Fan, Ventilation B-1053
Filter, Air EN-2310
Primary signal input, Serial 0P-1415-2000
Primary signal input, RJ45 J-1474
Primary signal output / Mirror signal input J-1470
Cable; RJ45, CAT5E, Shielded, 2’ W-1537
Cable; RJ45, CAT5E, Shielded, 20’ W-1547
Cable; 22 Awg 2-Pair, Dual Foiled, Single W-1234
Cable Assy; 20 pos Ribbon, 18”, Dual Row W-1387
Ribbon Assy; 10 Pos. @ 24”
0A-1000-0074
Ribbon Assy; 20 Pos, 24” 0A-1000-0016
Ribbon Assy; 20 Pos, 30” 0A-1000-0017
Ribbon Assy; 20 Pos, 42” 0A-1000-0019
Ribbon Assy; 20 Pos, 60” 0A-1000-0021
Ribbon Assy; 20 Pos, 72” 0A-1000-0022
Ribbon Assy; 20 Pos, 84” 0A-1000-0023
Interconnect Cable; RJ45 W-1921
Electrical Contact Cleaner/Lubricant CH-1020