DR Power Scout 8.25 (September 2005 - December 2006) - Manual (Page 25)

CALL TOLL FREE 1-800-DR-OWNER 21
CHAPTER 5
MAINTAINING THE DR SCOUT FIELD and BRUSH MOWER
This chapter covers regular maintenance procedures that will ensure the best performance and long life of
your machine. For engine maintenance, please refer to the Engine Owner’s Manual that came with your
mower. Service intervals listed in the checklist below supercede those listed in the Engine Owner’s Manual.
SOME OF THE FOLLOWING PROCEDURES REQUIRE ACCESS TO THE UNDERSIDE OF THE MACHINE. IF
YOU NEED TO TIP THE MACHINE BACK OR ON ITS SIDE (WITH THE DISCHARGE CHUTE FACING UP),
YOU MUST FIRST DISCONNECT THE SPARK PLUG WIRE, DRAIN THE OIL AND GAS, AND REMOVE THE AIR
FILTERS.
Regular Maintenance Check List
NOTE: Service intervals shown are considered maximum under normal operating conditions. Increase frequencies
under extremely dirty or dusty conditions.
Procedure
Before Each Use Every 25 Hours Every 100 Hours
Check Operator Presence Switch ▲
Check Engine Oil Level ▲
Check General Equipment Condition ▲
Check Blade for Sharpness ▲
Lubricate Wheel and Blade Clutch Levers* ▲
Lubricate Chain* and Clean around Idlers ▲
Check Tire Pressure ▲
Change Engine Oil and Filter** 1 st time 5 hours ▲
Clean Engine Exterior and Cooling Fins ▲
Check all Belt Tensions and Condition ▲
Check Cable connections ▲
Replace Air Filter and Precleaner** ▲
Replace Spark Plug ▲
* FLUID FILM ® lubricant or SAE 30 oil. NEVER use penetrating oil.
** The engine on your DR may not have a Precleaner or Oil Filter.