Polaris 2016 600 Switchback Assault 144 - Manual (Page 128)

126
TROUBLESHOOTING
Engine Troubleshooting
Problem Probable Cause Solution
Engine doesn't turn Seized engine • SEE YOUR DEALER. Seizure is a
result of poor lubrication, inade-
quate fuel supply, broken parts or
improper cooling.
Hydrostatic lock • Fuel may have entered the crankcase
while the vehicle was standing or
being transported. SEE YOUR
DEALER to correct the cause. Drain
plug(s) are located on the lower
crankcase for emergency draining.
Engine turns but fails
to start Faulty ignition • Install new spark plug(s). If engine
still fails to start, check for spark. If
there's no spark, SEE YOUR
DEALER.
No fuel to engine • Make sure the fuel valve is on.
• Make sure tank contains fuel.
• Ice may be in the fuel line, filter or
pump. Add isopropyl alcohol to the
fuel system.
• SEE YOUR DEALER.
Poor engine
compression • This indicates a major engine prob-
lem that must be repaired before
operating. SEE YOUR DEALER.
Engine lacks power Fouled or defective
spark plug(s) • Replace the plug(s).
Fuel filter (loss of
high RPM power) • SEE YOUR DEALER.
Plugged fuel filter or
tank pick-up sock • SEE YOUR DEALER.
Incorrect clutching • SEE YOUR DEALER.
Engine continually
backfires Faulty plug(s) • Change plug(s).
Fuel System • Dirt or ice may be in the fuel system
(deicer should be added to non-etha-
nol fuel at all times for assurance
against fuel line icing).
Incorrect throttle
freeplay or faulty
switch • SEE YOUR DEALER.
Engine requires
more than normal
pulls to start Poor fuel • Replace with fresh winter fuel.
Not enough fuel
getting to engine • SEE YOUR DEALER.
Plugged fuel filter or
tank pick-up sock • SEE YOUR DEALER.