Document Outline

• COVER
• INTRODUCTION
  • A FEW WORDS ABOUT SAFETY
• CONTENTS
• OUTBOARD MOTOR SAFETY
  • IMPORTANT SAFETY INFORMATION
  • SAFETY LABEL LOCATION
• CONTROLS AND FEATURES
  • CONTROL AND FEATURE ID CODES
  • COMPONENT AND CONTROL LOCATIONS
    • LH TYPE (TILLER HANDLE)
    • LRT AND XRT TYPES (REMOTE CONTROL)
    • REMOTE CONTROL BOX (OPTIONAL EQUIPMENT)
    • FUEL TANK (OPTIONAL EQUIPMENT)
    • TRIM METER (OPTIONAL EQUIPMENT)
    • TACHOMETER (OPTIONAL EQUIPMENT)
    • DIGITAL SPEEDOMETER (OPTIONAL EQUIPMENT)
    • DIGITAL TACHOMETER (OPTIONAL EQUIPMENT)
  • CONTROLS
    • LH TYPE (TILLER HANDLE)
    • IGNITION SWITCH
    • EMERGENCY STOP SWITCH CLIP AND EMERGENCY STOP SWITCH
    • THROTTLE GRIP
    • THROTTLE FRICTION ADJUSTER
    • GEARSHIFT LEVER
    • STEERING FRICTION ADJUSTER
    • TRANSOM ANGLE ADJUSTING ROD
    • TILT LEVER (LH TYPE)
    • LRT AND XRT TYPES (REMOTE CONTROL/OPTIONAL EQUIPMENT)
      • SIDE-MOUNT CONTROL TYPE
        • IGNITION SWITCH
        • EMERGENCY STOP SWITCH CLIP AND EMERGENCY STOP SWITCH
        • GEARSHIFT/THROTTLE CONTROL LEVER
        • FAST IDLE LEVER
        • POWER TRIM/TILT SWITCH
        • POWER TILT SWITCH (ENGINE PAN)
        • MANUAL RELIEF VALVE
  • COMMON CONTROLS
    • TILT LOCK LEVER
    • ENGINE COVER LATCHES
    • TRIM TAB
  • INSTRUMENTS
    • TRIM METER (LRT AND XRT TYPES/OPTIONAL EQUIPMENT)
    • TACHOMETER (ALL TYPES/OPTIONAL EQUIPMENT)
    • DIGITAL TACHOMETER (LRT AND XRT TYPES/OPTIONAL EQUIPMENT)
    • DIGITAL SPEEDOMETER (LRT AND XRT TYPES/OPTIONAL EQUIPMENT)
    • FUEL GAUGE (OPTIONAL EQUIPMENT)
  • INDICATORS
    • ALTERNATOR (ACG) INDICATOR
    • PROGRAMMED FUEL INJECTION (PGM-FI) INDICATOR
    • OIL PRESSURE INDICATOR
    • OVERHEAT INDICATOR
    • COOLING SYSTEM INDICATOR
  • OTHER FEATURES
    • OVERREV LIMITER
    • PORTABLE FUEL TANK (OPTIONAL EQUIPMENT)
    • FUEL FILLER CAP VENT KNOB (OPTIONAL EQUIPMENT)
    • FUEL PRIMING BULB
    • ANODES
• BEFORE OPERATION
  • ARE YOU READY TO GET UNDERWAY?
  • IS YOUR OUTBOARD MOTOR READY TO GO?
  • TILLER HANDLE HEIGHT/ANGLE ADJUSTMENT (LH TYPE)
• OPERATION
  • SAFE OPERATING PRECAUTIONS
  • BREAK-IN PROCEDURE
  • TRANSOM ANGLE ADJUSTMENT (LH TYPE)
  • PORTABLE FUEL TANK (OPTIONAL EQUIPMENT)
  • FUEL HOSE CONNECTIONS
  • FUEL PRIMING
  • STARTING THE ENGINE
  • EMERGENCY STARTING
  • STOPPING THE ENGINE
  • GEARSHIFT AND THROTTLE OPERATION
  • STEERING
  • CRUISING
  • TRIM
  • TRIM TAB
  • SHALLOW WATER OPERATION
  • MOORING, BEACHING, LAUNCHING
• SERVICING YOUR OUTBOARD MOTOR
  • THE IMPORTANCE OF MAINTENANCE
  • MAINTENANCE SAFETY
  • SPARE SWITCH CLIP AND EMERGENCY STARTER ROPE
  • TOOL KIT AND OWNER'S MANUAL
  • MAINTENANCE SCHEDULE
  • TRIM TAB ADJUSTMENT
  • MANUAL RELIEF VALVE
  • ENGINE COVER REMOVAL AND INSTALLATION
    • ENGINE OIL LEVEL CHECK
    • ENGINE OIL CHANGE
    • ENGINE OIL RECOMMENDATIONS
    • SPARK PLUG SERVICE
    • LUBRICATION POINTS
  • REFUELING
    • PORTABLE FUEL TANK (OPTIONAL EQUIPMENT)
  • FUEL RECOMMENDATIONS
    • FUEL FILTER/WATER SEPARATOR INSPECTION AND SERVICE
    • PORTABLE FUEL TANK AND TANK FILTER CLEANING (OPTIONAL EQUIPMENT)
  • ANODE REPLACEMENT
  • PROPELLER REPLACEMENT
• STORAGE
  • STORAGE PREPARATION
    • CLEANING AND FLUSHING
    • FUEL
    • ENGINE OIL
    • HOISTING THE OUTBOARD MOTOR
  • STORAGE PRECAUTIONS
  • REMOVAL FROM STORAGE
• TRANSPORTING
  • WITH OUTBOARD MOTOR INSTALLED ON BOAT
  • WITH OUTBOARD MOTOR REMOVED FROM BOAT
• TAKING CARE OF UNEXPECTED PROBLEMS
  • ENGINE WILL NOT START
  • HARD STARTING OR STALLS AFTER STARTING
  • ENGINE OVERHEATS
  • FUSES
  • ELECTRIC STARTER WILL NOT OPERATE
  • BATTERY WILL NOT CHARGE
  • FUSE REPLACEMENT
  • OIL PRESSURE INDICATOR GOES OFF AND ENGINE SPEED IS LIMITED
  • DIGITAL TACHOMETER
  • OVERHEAT INDICATOR COMES ON AND ENGINE SPEED IS LIMITED
  • DIGITAL TACHOMETER
  • SUBMERGED MOTOR
• TECHNICAL AND CONSUMER INFORMATION
  • TECHNICAL INFORMATION
    • SERIAL NUMBER LOCATIONS
    • BATTERY
    • EMISSION CONTROL SYSTEM INFORMATION
    • STAR LABEL
    • SPECIFICATIONS
  • CONSUMER INFORMATION
    • Honda PUBLICATIONS
    • CUSTOMER SERVICE INFORMATION
    • DISTRIBUTOR'S LIMITED WARRANTY
    • ACCESSORIES AND REPLACEMENT PARTS
    • EMISSION CONTROL SYSTEM WARRANTY
• INDEX