Troubleshooting 8 troubleshooting – Minuteman E Ride 26 User Manual
Page 54
54
Troubleshooting
8
Troubleshooting
Problem
Possible Cause
Remedy
Poor water pick-up
Worn or torn squeegee blades
Rotate or replace blades
Squeegee out of adjustment
Adjust so blades touch floor evenly
across entire width
Recovery tank full
Empty recovery tank
Recovery tank drain hose leak
Secure drain hose cap or replace
Recovery tank lid gasket leak
Replace gasket lid cover properly
Debris caught in squeegee
Clean squeegee
Vacuum hose clogged
Remove debris and flush hose
Using too much solution
Adjust solution control valves
Vacuum hose to squeegee or recovery
tank disconnected to squeegee or dam-
aged
Reconnect or replace squeegee hose
Poor scrubbing performance
Worn brushes
Rotate or replace brushes
Wrong brush or cleaning chemical
Consult Minuteman
Debris caught on scrub brushes
Remove debris
Moving machine too fast
Slow down
Low battery charge
Recharge batteries
No solution to off-aisle wand spray jet
Solution tank empty
Refill solution tank
No FWD/REV drive
Drive system speed controller.
Check error fault codes