Southbend NODR14: Floor Model Rinse Station - Manual (Page 16)

OPERATION
12 L20-393, rev.1 (08/14)
2. OPERATION
An operator’s manual for your appliance’s specific control type should be included with this manual.
Refer to that manual prior to operating this appliance.
2.1. OPERATIONAL FEATURES
The diagram below outlines some of the key operational components of your appliance, see Figure 3.
Refer to the following sections of this manual to learn more about these features.
1. Cook
Tank
2. Controller (Digital 2 Button Control)
Controls the water temperature inside the cook tank.
Programmable timers are located on the controller, Buttons 1 & 2.
Soft ON/OFF Press once for ON, Press & Hold for Off
When Control is ON, Press the ON/OFF button once to Toggle between Boil and Simmer Mode.
3. Door
(Shown Open)
Provides access to the drain valve handle, high temperature reset button(s) and gas valve, pilot,
burners and shutoff valves.
4. Drain Valve Handle (Shown in the closed position)
Opens the drain valve so water can be drained from the cook tank.
This unit is standard with a drain valve interlock feature, the appliance will stop heating if the drain
valve is opened.
5. Drain Outlet
Water exits the cook tank through the drain outlet when draining or overflowing.
6. Overflow Line
When the cook tank water level reaches the overflow, water will flow unobstructed through the
overflow line and eventually exit the appliance through the drain outlet.
7. High Temperature Reset Button
This button may need to be pressed in the event that the high temperature limit has tripped.
8. Basket Hanger
For hanging and/or draining baskets when they are outside of the cook tank.
9. Manual Water Fill Knob (Optional Equipment)
Fills the cook tank with water from an optional rear water connection.
10. Gas Supply Shut Off Valve
Manual valve to control off the gas supply to the appliance.
11. Gas Valve Knob
The gas valve controls the flow of gas to the pilot and burners.
Turning the gas valve knob to the OFF position shuts off the gas supply to the pilot and burners.
12. Self Cleaning Burner System (SCBS) Runner Tube
The runner tube supplies a small amount of gas to the entrance of the main burners to activate
the self cleaning feature.
13. Pilot
The pilot lights the burners when the water in the cook tank requires more heat.
14. Burners
These main burners provide flame to heat the water inside the cook tank.