Metro Starsys Mobile Power - Manual (Page 2)

2
TABLE OF CONTENTS
COPYRIGHT NOTICE ........................................................................................................................................................................................................ 2
SAFETY INSTRUCTIONS ................................................................................................................................................................................................... 2
INTRODUCTION ................................................................................................................................................................................................................ 3
GETTING STARTED WITH CART ...................................................................................................................................................................................... 4
OPERATION OF MOBILE POWER CART .......................................................................................................................................................................... 7
MAINTENANCE & REPLACEMENT PARTS LISTS ............................................................................................................................................................ 11
WIRING DIAGRAM ............................................................................................................................................................................................................ 15
BASIC TROUBLESHOOTING ............................................................................................................................................................................................ 16
COPYRIGHT NOTICE
This manual is copyrighted. All rights reserved. This manual may be printed for personal use only. This manual, whole
or in part, may not be copied, photocopied, reproduced, translated, or reduced to any electronic medium or machine-
readable form for distribution. This manual, whole or in part, may not be modifi ed without prior consent, in writing, from
InterMetro Industries Corporation.
Copyright © 2012 by InterMetro Industries Corporation, 651 North Washington Street,
Wilkes-Barre, PA 18705, U.S.A.
Phone: 1-800-992-1776
http://www.metro.com/support
InterMetro Customer Service: For all customer service related issues, or if you need technical assistance, please call
our customer service department at:
1-800-992-1776 Americas
+31 76 58 77550
Europe
+9714 811 8286 Middle East
+65 6567 8003 Asia-Pacifi c
SAFETY INFORMATION
This section contains important safety and operating instructions for Starsys mobile power cart. Please read all
instructions on the cart before putting into service.
CAUTION : User maintenance consists solely of cleaning and minor external adjustments. For safety purposes, all
servicing must be performed by qualifi ed service personnel only. For all service items, please contact
InterMetro Customer Service.
CAUTION : Do not operate the Starsys cart, if it has received a severe impact or has been otherwise physically
damaged. Please have a qualifi ed service person inspect both the Starsys cart in conjunction with its power
supply for any performance or safety hazard prior to putting back into service.
CAUTION : To prevent damage to any cords or connectors when disconnecting, always grasp and pull by the connector
and not the cord. Do not operate the Starsys cart with damaged cords or connectors. Please replace the
damaged component immediately. Contact InterMetro Customer Service for replacement parts and service.
DANGER: Starsys cart and the power supply are not for use in hazardous (classifi ed) locations. Do not use nor recharge
the power supply battery, in oxygen enriched areas; areas where fl ammable anesthetics are used or stored;
or any other hazardous, classifi ed location.
DANGER: The maximum design load (safe working load limit) for the Starsys cart is 300 lbs.(136 kg.).
THE RECEIVER OF THIS PRODUCT IS RESPONSIBLE FOR FREIGHT DAMAGE CLAIMS .
• This equipment must be opened immediately for inspection.
• All visible damages must be reported to freight co. within
48 hours , and must be noted on freight bill at time of
delivery.
• Concealed damage is your responsibility - you must advice carrier of any loss or damage within 15 days after
receipt of material.
• If there is damage, retain original packaging for inspectors.