Montigo M38DV PRC - Manual (Page 2)

XG0204 04/05 Page 
Panorama Direct Vented Fireplace
Introduction
The 38 Series Direct Vent - Panorama is a multi-sided Gas Fireplace
with an adjustable center burner and air-circulating fans. It is avail-
able in two models:
 Model M38DV-PRC (continuous pilot)
 Model M38DV-PRC-I (intermittent pilot)
This manual covers installation, operation and maintenance. Light-
ing, operation and care of this fireplace can be easily performed by
the homeowner. However, all installation and service work should be
performed by a qualified or licensed installer, plumber, or gasfitter
who is qualified or licensed by the state, province, region, or govern-
ing body in which the appliance is being installed.
This manual covers both models and unless otherwise specified, the
designation M38DV-PRC refers to both models. Sections which are
specific to a particular model are marked with a
sym-
bol, plus the appropriate model number.
The M38DV-PRC is rated for:
 Natural Gas at 30,000 BTU/H (8.78 Kilowatts) max. input, and
24,000 BTU/H (6.86 Kilowatts) min. input
 Propane at 28,000 BTU/H (8.20 Kilowatts) max. input, and
22,000 BTU/H (6.40 Kilowatts) min. input
The Montigo warranty will be voided by, and Montigo disclaims any
responsibility for, the following actions:
 Modification of the fireplace and/or components including Direct-
Vent assembly or glass doors.
 Use of any component part not manufactured or approved by
Montigo in combination with this Montigo fireplace system.
 Installation other than as instructed in this manual.
Consult your local Gas Inspection Branch on installation require-
ments for factory-built gas fireplaces. Installation & repairs should be
done by a qualified contractor.
Installations in Canada must conform to the current CAN/CGA
B-149.1 and .2 Gas Installation Code and local regulations. This fire-
place's fans must be electrically grounded in accordance with CSA
C22.1 Canadian Electrical Code Part 1 and/or Local Codes.
Installations in the USA must conform to local codes, or in the
absense of local codes to the National Fuel Gas Code, ANSI Z223.1-
1988. The fans must be grounded in accordance with local codes
or, in the absence of local codes, with the National Electrical Code,
Table Of Contents
Introduction ............................................................................... 2
Installation ..........................................................................3 - 12
Installing the Fireplace Shell .......................................... 3
Installing the Gasline ...................................................... 4
The Remote Switch ........................................................ 4
Direct Vent Installation ................................................... 4
General Requirements ...................................... 4
Terminations ...................................................... 5
Horizontal Venting Runs .................................... 6
Vertical Venting Runs ........................................ 7
Construction around the fireplace
Facing .............................................................. 8
Mantels and Surrounds ..................................... 8
Wiring ............................................................................ 9
Fans ............................................................................... 9
Removing and Installing the Doors .............................. 10
Operation ............................................................................10-13
Burner Adjustment................................................... 11-13
Maintenance .......................................................................14-15
Warranty .................................................................................. 16
Appendix A - Termination Locations ....................................... 17
Appendix B - Spare Parts & Accessories ................................ 18
CAUTIONS
Due to its high operating temperatures, the appliance
should be located out of traffic & away from furniture and
draperies.
• Children and adults should be alerted to the hazards
of the high surface temperature, which could cause
burns or clothing ignition.
• Young children should be carefully supervised when
they are in the same room as the appliance.
• Clothing or other flammable materials should not be
placed on or near the appliance.