KTM ENDURO 640 LC4 - Manual (Page 48)

ENGLISH
47
TROUBLE SHOOTING
»
TROUBLE CAUSE REMEDY
High oil consumption Buckling gear ventilation hose
Engine oil level too high
Engine oil too thin (viscosity)
Readjust or replace ventilation hose
Check engine oil level when the engine is warm; correct if
necessary
Use thicker engine oil; see chapter „Engine oil“
Headlight and parking light fail Blown fuse Enduro: Replace fuse (5).
Supermoto: Replace fuse (4).
Flasher lights, brake light, fan and
horn fail
Blown fuse Enduro: Replace fuse (4).
Supermoto: Replace fuse (3).
The NEUTRAL lamp is not on even
though the gear is in NEUTRAL
Defect neutral switch.
Loose connections, defect cable.
Connect cable to ground; neutral switch must be replaced
if indicator lamp lights up.
Check connections and cables.
The battery is discharged The ignition (power consumer) has-
n’t been switched off
The battery isn’t charged by the gen-
erator because
echarge the battery according to the relevant instructions.
Remove seat and check voltage regulator connections; volt-
age regulator and generator should be checked by a KTM
dealer.
No values are visible in the
Tripmaster display
Main fuse melted through Replace the main fuse under the seat
No speed display. Defective sensor cable or oxidized
socket connector.
Check the sensor cable for damage and replace it if
necessary.
Remove the headlight mask and check the socket
connector.
Contact a KTM dealer.