King Kooker 2206 Heavy Duty Portable Propane Outdoor Smoker with Cooker Package - Manual (Page 17)

17
WARNING
NEVER PUT HANDS OR FACE DIRECTLY OVER BURNER WHILE LIGHTING.
FIGURE 1
FIGURE 3
FIGURE 5
FIGURE 4
FIGURE 2
(.61 m)
LIGHTING INSTRUCTIONS
THE SMOKER/COOKER MUST NOT BE LIT UNTIL THE PRECEDING
PLACEMENT INSTRUCTIONS HAVE BEEN COMPLETELY FOLLOWED.
1. Check the casting (burner) to make sure it is set up as per the illustration (Figure 1). When using this
appliance as a smoker, never light the burner with the smoker door closed. Never lean into the
smoker chamber while lighting. Locate the plate embossed with HOT on the stack on top of the
cabinet. Turn the plate until it is fully exposed. This signals that the smoker is HOT while in use.
2. Make certain that the regulator control is turned to OFF by turning it counterclockwise until it reaches the
stop (Figure 2).
3. Open cylinder control valve by turning it counterclockwise as per the diagram (Figure 2).
4. Insert a multipurpose lighter through the hole in the shroud as per Figure 4, or use a paperbook match
placed above the casting as per Figure 3 (smoker cabinet not placed on base). Turn the regulator
control toward the “ON” position until ignition occurs. Turning the regulator control clockwise increases
the gas pressure to the burner and hence the flame size (Figure 2). When lighting the stove, if ignition
does not occur in 3 to 5 seconds, turn the regulator and cylinder valve off. Wait 5 minutes for gas to
disperse. Repeat procedure.
5. Check that the flame is blue and that the flames are emitted from every port in the casting. If not, rotate
the air shutter position until there is a blue flame. Opening the shutter too much will cause the flame to
“Lift” off the burner (Figure 5).
If there is a yellow flame, or if some ports have no flame, this indicates there may be an obstruction in
the venturi tube or ports. Check the maintenance instructions on pages 19-20 for more information
regarding a yellow flame.
6. Always monitor the flame throughout the cooking process. If at any point in the cooking process the
flame is accidentally extinguished, immediately turn the regulator and cylinder valve OFF. Open main
smoker door slowly (if applicable), wait 5 minutes for gas to disperse and relight the cooker according to
the lighting instructions (#1-#5) in this section.
WARNING