Van Air Systems SG-23 Cartridge - Manual (Page 3)

Van Air Systems, Inc. Silica Gel (Indicating & Non-Indicating) Material Safety Data Sheet Page 2 of 2
Date Prepared: May 1, 2000
Section 5 – Reactivity Information
Stability (Conditions to avoid):
Stable. (Handling near flammable gases or vapors.)
Incompatibility (Materials to avoid): None expected.
Hazardous decomposition/byproducts: None expected.
Hazardous Polymerization: Will not occur.
Section 6 – Health Hazard Information
Potential Health Effects:
Inhalation, ingestion, skin and eye contact.
Health Hazards (acute and chronic): None known.
Carcinogenicity: No.
NTP: No.
IARC Monographs: No. (Yes for indicating material)
OSHA Regulated: No.
Signs and Symptoms of Exposure: Generally aggravated by exposure desiccant action may cause skin
dryness or eye irritation. NOTE: Indicator Only – LD50 (oral, rat):
766 Mg/Kg (for Cobalt Chloride Hexahydrate, RTECS 1985-86).
Emergency and First Aid Procedures
Eyes:
Flush with water for at least 15 minutes.
Skin: Wash with soap and water.
Inhalation: Remove to fresh air. If unconscious seek immediate medical
attention.
Ingestion:
Physicians Note:
Indicator Type Only: Beads impregnated with Cobalt Chloride,
therefore induce vomiting if victim has swallowed large quantities.
IF IRRITATION PERSISTS SEEK MEDICAL ATTENTION
Section 7 – Precautions for Safe Handling and Use
Small/Large Spills:
Sweep or shovel up immediately due to slippery conditions (beads).
Dispose at appropriate waste disposal facility.
Waste Disposal Method: Comply with local regulations for non-hazardous chemical disposal.
Handling & Storage: Keep containers tightly closed and store in a cool, dry place.
Other precautions: Take precautionary measures against static discharge when handling
near flammable gases or vapors. Information given herein is offered
in good faith as accurate, but without guarantee. Conditions of use
and suitability of the product for particular uses are beyond our
control; all risks of use of the product are therefore assumed by the
user and we expressly disclaim all warranties of every kind and
nature, including warranties of merchantability and fitness for a
particular purpose in respect to the use or suitability of the product.
Section 8 – Control Measures
Respiratory Protection (specific type):
Use a NIOSH approved dust mask if excessive dust is present.
Ventilation: Natural ventilation or local exhaust.
Mechanical, Special and other Exhaust – Not applicable.
Protective Gloves: None required however follow good personal hygiene practices.
Eye Protection: Safety glasses or goggles for dust and dirt.
Other Protective Clothing & Equipment: Work clothes and work gloves.
Work/Hygienic Practices:
Wash thoroughly after handling.