JLG 3248RS/10RS Service Manual - Manual (Page 35)

SECTION 3 - CHASSIS & SCISSOR ARMS
3121273 – JLG Lift – 3-3
3.3 BATTERY CHARGER
The Battery Charger is located at the rear of the machine
under the rear access cover, remove the cover to gain
access to the charger.
Battery Charger Location
BATTERY
FILLER CAP
FLUID LEVEL OF FULLY
CHARGED BATTERY
VENT TUBE
PLATES
1/8 "
Figure 3-3. Battery Fluid Level
1. AC Voltage - Input Cable
2. Charger Interlock Cable 3. DC Power Cable to Batteries
Figure 3-4. Battery Charger
Table 3-1. Battery Charger Specs
BATTERY CHARGER SPECIFICATION
OUTPUT
Nominal DC Output Voltage
24V
Maximum DC Output Voltage 33.6V
Maximum DC Output Current 25A
Maximum Interlock Current
1A
INPUT
AC Input Voltage
85-265VAC
Nominal AC Input Voltage 120VAC - 230VAC RMS
AC Input Frequency 45-65 HZ
Maximum AC Input Current 12A RMS@108VAC
OPERATION
Charging Indicator
Yellow LED
Battery Fault Indicator Flashing Yellow LED
100% Charge Indicator Green LED
Charger Fault Indicator Red LED
PROTECTION
Output Reverse Polarity
Electronic Protection - Automatic
Reset
Output Short Circuit
Electronic Protection - Automatic
Reset
AC Overload Current Limited
DC Overload Current Limited
MECHANICAL
Operating Temperature
–22° F to +122°F
(–30°C to +50°C)
Housing Shock and Water Resistant Aluminum
1
2
3