Battery Tender Waterproof 800 International - 12V @ 800 mA (PN 022-0150-DL-WH) User Instructions - Manual (Page 4)

7
AMBER LIGHT ON STEADY (Both models) – Whenever the amber light
is on steady, a battery is connected properly and the charger is charging
the battery. The amber light will remain on until the charger completes the
charging stage.
GREEN LIGHT FLASHING (1.25A only) - When the green light is
flashing, and the amber light is on, the battery is greater than 80%
charged and may be removed from the charger and used if necessary.
Whenever possible, leave the battery on charge until the green light is
solid.
GREEN LIGHT ON STEADY (Both models) - When the green light stops
flashing and burns steady, the charge is complete and the battery can be
returned to service if necessary.
ALTERNATING AMBER & GREEN LIGHTS FLASHING (Both models)
– This is abnormal and most likely indicates that the battery is sulfated.
STATUS INDICATING SYMBOLS: The following symbols are located
next to the 2 status indicator lights, one amber, one green (1.25 A) or
on each side of the single status indicator light that glows either amber
or green (800 mA).
The symbol next to the AMBER light represents a partially
charged battery. The solid band across the bottom is green in
color. The background is yellow. The green area indicates the
charged portion of the battery and the yellow area represents
the uncharged portion.
The symbol next to the GREEN light represents a fully charged
battery. The entire area inside the battery outline is green.
TROUBLESHOOTING CHECK LIST:
1. NEITHER OF THE CHARGER LIGHTS TURN ON AFTER THE AC POWER
PLUG IS CONNECTED TO THE AC ELECTRICAL OUTLET: For the 1.25A
model: Check the charger AC power plug connection at the AC electrical outlet.
Verify that the AC electrical outlet is functioning properly by plugging in another
appliance or a voltmeter. For the 0.8 A model, also make sure that the charger output
is properly connected to the battery.
2. THE CHARGER GREEN LIGHT GOES ON IMMEDIATELY WHEN AC
POWER IS APPLIED TO THE CHARGER: The charger connections at the
battery may be intermittent, the battery may be defective, or the battery might already
be fully charged.
3. CHARGER IS CHARGING BUT THE GREEN LIGHT DOES NOT TURN ON
IN A REASONABLE AMOUNT OF TIME: The battery may be large and requires
more time to fully charge than originally expected, there may be another appliance
drawing electric power from the battery while it is charging, or the battery may be
defective. Also, a newly purchased battery may not be fully charged and may take
longer to charge initially.
4. THE AMBER LIGHT COMES ON AGAIN AFTER THE GREEN LIGHT
CAME ON. There may be another appliance drawing electric power from the battery
causing its voltage to drop below the reset level. The battery charger then goes back
into full charge mode. Also, the charger connections at the battery may be intermittent
or the battery may be defective.
8
SPECIFICATION SUMMARY:
Technical Specifications (0.8 Amp or 1.25 Amp Models)
Input Voltage 100 to 240 VAC
Input Frequency 50 / 60 Hz
0.275 or 0.3 Arms @ 100 VAC Input Current
0.08 or 0.1 Arms @ 240 VAC
Output Current Bulk Charge 800 mADC Constant
or 1.25 ADC
Absorption Charge 14.5 VDC Constant Output Voltage
Maintenance Charge 13.2 VDC Constant
Input to Output 2500 VAC
Input to Chassis 2500 VAC
Electrical
Isolation
Output to Chassis 500 VAC
Operating Temperature -20 ° C to +50 ° C
Enclosure Protection Against
Foreign Object & Water Ingress
IP67
Charger Case Dimensions:
0.8 Amp: 4.25 in (108 mm) L x 2.75 in (70 mm) W x1.5 in (38 mm) H.
1.25 Amp: 5.4 in (137 mm) L x 2.9 in (74 mm) W x1.6 in (41 mm) H.
Note: For both models, allow an additional 1 in (25.4 mm) on each
end of the length dimension for safe bend of AC and DC power cord
strain relief.
Shipping Weight:
0.8 Amp: Approx. 2.0 lbs (0.91 kg)
1.25 Amp: Approx. 2.5 lbs (1.2 kg)
WITH:
Accessories &
Retail Packaging
Acceptable Battery Cell Type, Number, and Ah Capacity
Charger Model Cell Type Number Ah Capacity
12V, 0.8 Amp
Lead Acid, All
but Gel Cell
6 Cells Up to 65 Ah
12V, 1.25 Amp Lead Acid, All
but Gel Cell
6 Cells Up to 95 Ah
DELTRAN CORPORATION
801 U.S. Highway 92 East
DeLand, Florida 32724
Phone 386-736-7900 FAX 386-736-0379
www.batterytender.com