Microstrip details, Production guidelines, Hand assembly – Linx Technologies RXM-GPS-F4 User Manual

Page 23: Automated assembly, Castellations pcb pads soldering iron tip solder

Advertising
background image

40

41

Microstrip Details

A transmission line is a medium whereby RF energy is transferred from one
place to another with minimal loss. This is a critical factor, especially in
high-frequency products like Linx RF modules, because the trace leading
to the module’s antenna can effectively contribute to the length of the
antenna, changing its resonant bandwidth. In order to minimize loss and
detuning, some form of transmission line between the antenna and the
module should be used, unless the antenna can be placed very close
(<

1

8

in) to the module. One common form of transmission line is a coax

cable; another is the microstrip. This term refers to a PCB trace running
over a ground plane that is designed to serve as a transmission line
between the module and the antenna. The width is based on the desired
characteristic impedance of the line, the thickness of the PCB, and the
dielectric constant of the board material. For standard 0.062" thick FR-4
board material, the trace width would be 111 mils. The correct trace width
can be calculated for other widths and materials using the information
below. Handy software for calculating microstrip lines is also available on
the Linx website, www.linxtechnologies.com.

Trace

Board

Ground plane

Example Microstrip Calculations

Dielectric Constant

Width/Height

Ratio (W/d)

Effective Dielectric

Constant

Characteristic

Impedance (Ω)

4.80

1.8

3.59

50.0

4.00

2.0

3.07

51.0

2.55

3.0

2.12

48.0

Figure 51: Microstrip Formulas

Figure 52: Example Microstrip Calculations

Production Guidelines

The module is housed in a hybrid SMD package that supports hand and
automated assembly techniques. Since the modules contain discrete
components internally, the assembly procedures are critical to ensuring
the reliable function of the modules. The following procedures should be
reviewed with and practiced by all assembly personnel.

Hand Assembly

Pads located on the bottom
of the module are the primary
mounting surface (Figure 53).
Since these pads are inaccessible
during mounting, castellations
that run up the side of the
module have been provided to
facilitate solder wicking to the
module’s underside. This allows
for very quick hand soldering
for prototyping and small volume production. If the recommended pad
guidelines have been followed, the pads will protrude slightly past the
edge of the module. Use a fine soldering tip to heat the board pad and the
castellation, then introduce solder to the pad at the module’s edge. The
solder will wick underneath the module, providing reliable attachment. Tack
one module corner first and then work around the device, taking care not
to exceed the times in Figure 54.

Automated Assembly

For high-volume assembly, the modules are generally auto-placed.
The modules have been designed to maintain compatibility with reflow
processing techniques; however, due to their hybrid nature, certain aspects
of the assembly process are far more critical than for other component
types. Following are brief discussions of the three primary areas where
caution must be observed.

Castellations

PCB Pads

Soldering Iron
Tip

Solder

Figure 53: Soldering Technique

Figure 54: Absolute Maximum Solder Times

Warning:

Pay attention to the absolute maximum solder times.

Absolute Maximum Solder Times

Hand Solder Temperature: +427ºC for 10 seconds for lead-free alloys

Reflow Oven: +240°C max (see Figure 55)

Advertising