Perfect Flame 720-0522 - Manual (Page 17)

3. Apply the soap solution to all gas fittings. Soap bubbles will appear where a leak is present.
4. If a leak is present, immediately turn the gas supply “OFF” and tighten leaky fittings.
5. Turn the gas back “ON” and recheck.
6. Should the gas continue to leak from any of the fittings, turn the gas supply “OFF” and contact
customer service at 1-877-323-5263.
7. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be replaced prior to the
outdoor cooking gas appliance being put into operation.
Only those parts recommended by the manufacturer should be used on the grill. Substitutions will void
the warranty.
INSTALLER FINAL CHECK
• Maintain specified clearance of 24 inches from combustible materials and construction.
• All internal packaging has been removed.
• The hose and regulator are properly connected to the Liquid Propane cylinder.
• The unit has been tested and is free of leaks.
• The gas supply shut off valve has been located.
• All burners are installed.
• Keep the instruction manual for future reference.
OPERATING INSTRUCTIONS
General Use of the Grill
Each main burner is rated at 10,000 BTU/Hr. The main grill burners encompass the entire cooking area
and are side ported to minimize blockage from falling grease and debris. Above the burners are flame
tamers. The igniter knobs are located on the center portion of the valve panel. Each rotary igniter is
labeled on the control panel.
Using the Grill
Grilling requires high heat for searing and proper browning. Most foods are cooked at a “HI” heat setting
for their entire cooking time. However, when grilling large pieces of meat or poultry, it may be necessary
to turn the heat to a lower setting after the initial browning. This method cooks the food thoroughly without
burning the outside.
WARNING WARNING
Storage of an outdoor cooking gas appliance Cylinder must be stored outdoors out of the
indoor is permissible only if the cylinder is reach of children and must not be stored in
disconnected and removed from the outdoor a building, garage or any other enclosed
cooking gas appliance. area.
WARNING
1. Do not store spare Liquid Propane cylinders under or near this appliance.
2. Never fill the cylinder beyond 80 percent capacity.
3. If the information above is not followed exactly, a fire causing death or serious injury may occur.
WARNING
1. The grill and its individual shutoff valve must be disconnected from the gas supply piping system
during any pressure testing of that system at test pressure in excess of 1/2-in. psi.(3.5kpa).
2. The grill must be isolated from the gas supply piping system by closing its individual; manual
shutoff valve during any pressure testing of the gas supply piping supply at test pressure equal to
or less 1/2-in. psi.(3.5kpa).
17