Bradley Smoker MG-2/BIR3 - Manual (Page 12)

Express® Lavatory System - MG Series with Battery Infrared Control
MG-2/BIR3
Installation Instructions
12 8/23/07 Bradley Corporation • 215-1510 Rev. D; ECN 07-815
Cleaning and Maintenance Instructions
IMPORTANT: Strong alkaline or acid-based chemicals and cleansers should not be
used to clean the MG-2/BIR3 Express®. If these chemicals come in
contact with the Terreon® surface, wipe off the surface immediately
and flush with soapy water. Avoid unnecessary or prolonged contact
with hot pans and objects.
Terreon® and panel maintenance
The bowl, sprayhead and pedestal end caps are made of Terreon®, a solid cast polyester resin
material. Terreon® resists chemicals, stains, burns and impact, and is repairable with everyday
cleaners or fine-grit abrasives. The panel is made of stainless steel. With regular cleaning, your MG-
2/BIR3 Express® will provide years of dependable service.
Stainless Steel Access Panel cleaning
Stainless steel is extremely durable, and maintenance is simple and inexpensive. Proper care,
particularly under corrosive conditions, is essential. Ordinary deposits of dirt and grease are quickly
removed with soap and water. Whenever possible, the metal should be thoroughly rinsed and dried
after washing. To remove tightly adhering deposits, use stainless steel polishing powder. In all cases,
rub in the direction of the stainless steel grain.
IMPORTANT: Never use ordinary steel wool or steel brushes on stainless steel.
Always use stainless steel wool or stainless steel brushes.
Avoid prolonged contact with chlorides, bromides, thiocyanates, and iodides on stainless steel
equipment, especially if acid conditions exist. Do not permit salty solutions to evaporate and dry on
stainless steel. The appearance of rust streaks on stainless steel leads to the belief that the stainless
steel is rusting. Look for the source of the rust in some iron or steel particles which may be touching,
but not actually a part of the stainless steel structure. NOTE: Strongly acidic or caustic cleaners may
attack the steel causing a reddish film to appear. The use of these cleaners should be avoided.
Terreon® Bowl, Sprayhead and Pedestal End Cap cleaning
IMPORTANT: To sustain original finish, additional care is recommended for dark
colored solid surfaces to maintain highest quality color. The original
luster can be maintained by periodically applying furniture polish,
mineral oil or a solid surface cleaner or polish. For more information
on restoring dark colors, see Bradley document #1505. Length of
time between applications varies with usage.
• For regular cleaning, use standard commercial or household products such as Formula 409® or
Windex®.
• Remove tough stains with Ajax®, Comet® or Soft-Scrub® and a green Scotch-Brite® pad or
lightly sand in a circular motion with 240 grit wet/dry sandpaper. The finish can be renewed with
a maroon Scotch-Brite® pad.
• Remove scratches with a green Scotch-Brite® pad. The finish can be renewed with a maroon
Scotch-Brite® pad. Remove hard water build-up with a mild solution of vinegar and water.
* Use of brand names is intended to indicate a type of cleaner and does not constitute an
endorsement.
** It is emphasized that all products should be used in strict accordance with package instructions.
• Repair kit: A repair kit is available from Bradley to repair/patch the Terreon® bowl and shelf.
Contact your Bradley representative to order a repair kit and be sure to specify color.