BoonDocker ARCTIC CAT: Non-turbo Control Box 700/800/1000 (V3) User Manual
Page 19
BoonDocker – 1585 Hollipark Dr. Idaho Falls, ID 83401 – 208-542-4411 / 877-522-7805
www.boondockers.com – email:
– fax: 208-524-7381
Revised 12-14-07
Page 19 of 19
Moisture on LCD:
Condensation is normal if the Control Box is quickly moved from a cold to a warm environment.
In some cases, the Control Box enclosure may no longer be sealing properly. If such problems
persist, contact Boondocker to determine if resealing the box is necessary.
Check Engine light:
Make sure the wires in the EFI harness are correct and check for a bad connection in the wiring
harness. Recheck all connectors and be sure each is completely latched. Also inspect each wire to
make sure there are no frayed, broken, or melted wires. Look at the seals on the back of each
connector – if a pin has backed out, its wire seal will be protruding out of the connector more than
the rest.
Engine won’t start
when Hot:
A problem has been known to occur on some sleds involving the engine temperature sensor when
the engine is hot and especially after it has been sitting for a while (gets heat soaked) that will cause
the engine not to start. Unplug the temp sensor (yellow connector located down by where the rope
goes into the recoil) – this will cause the engine to add extra fuel during startup. Pull the engine
over once or twice – it usually pops. Then plug the sensor back in and the engine should operate
normally.
XI. Warranty, Terms & Conditions
Returned Goods – No merchandise will be accepted without prior approval. A RMA number (Return Merchandise
Authorization) provided by Boondocker is required before a return will be accepted. A 20% handling and restocking
charge will be applied to returned merchandise. No unauthorized returns will be accepted.
Limited Warranty – Boondocker warrants its product to the original purchaser against workmanship defects for a period
of 90 days, commencing from the date of product delivery to the Consumer.
Maximum Liability – The maximum liability of Boondocker in connection with this warranty shall not under any
circumstances exceed the price of the product claimed to be defective.