Winco MD6L - Manual (Page 15)

PAGE 13 60706-121
Engine Unbalanced Consult local engine dealer.
ENGINE
DIESEL ENGINE WILL NOT CRANK.
Corroded Battery Cable Remove cables from battery and clean.
Connections
Battery Dead Check battery with a hydrometer. Recharge or replace as required.
CAUTION: SEE BATTERY CONNECTION ON PAGE 4
Defective Starter or Test start solenoid and starter. Refer to engine manufacturer's manual.
Solenoid
Selector Switch Defective Check selector switch for proper continuity. Replace.
CRANKS BUT WILL NOT START.
Out of Fuel Fill fuel tank.
Air in the Fuel Lines Bleed air out of fuel system. See engine manual.
Misadjusted or Defective Troubleshoot and Replace. See engine manual for details.
Fuel Solenoid
Water/Fuel Separator Full Drain water from separator.
of Water
Fuel Filter Plugged Replace filter(s).
STARTS BUT WILL NOT RUN.
Defective Holding Coil in Troubleshoot and replace.
Fuel Solenoid
Low Battery Test and recharge or replace. Be sure to check battery charging circuit
for proper charge operation.
CAUTION: SEE BATTERY CONNECTION ON PAGE 4
ENGINE SPEED DROPS TOO LOW UNDER LOAD
Air Cleaner Plugged Replace.
Generator Overloaded Remove external load and troubleshoot generator.
Water/Fuel Separator Full Drain water from separator.
of Water
Fuel Filter Plugged Replace filter(s).
Injector Pump Defective Repair or replace.
LIGHT TOWER