Winco MD6L - Manual (Page 4)

60706-121 PAGE 2
safely.
B. Never attempt to lift the equipment unless you
are certain the lifting device has sufficient capacity.
C. Never allow the equipment to swing while
suspended.
D. Be certain the supporting structure is adequate
to handle the load.
8. TOWING THE EQUIPMENT - When towing this
equipment, always use a vehicle large enough for safe
operation.
A. Never tow without the safety chains secured.
B. Always use the proper size hitch ball on the
vehicle.
C. Never attempt to tow with a vehicle that does
not have side mirrors installed.
D. Always retract the tower and lock it into the
horizontal retracted position before moving the unit.
E. Always put all jacks into (“foot up”) horizontal
position before moving the tower.
9. TOWER ERECTION - This equipment will become
top heavy very quickly as the tower is raised. Always
follow the proper sequence raising or lowering the
tower.
A. Always extend the leveling jacks and level the
unit before lifting the tower from its horizontal position.
B. Always lift the tower to the full vertical position
(or tilt position) and lock in place before removing the
pin to extend the tower.
C. Never attempt to lower the tower to the horizon-
tal position without the tower FULLY RETRACTED and
locked.
D. Always check for proper overhead clearance
before attempting to erect the tower. Never raise in the
vicinity of overhead power lines.
E. Never allow anyone to walk under the tower
during the raising or lowering operation.
MODULAR GENERATOR/ LIGHT-
ING SYSTEM DESCRIPTION
WINCO's uniquely designed MLS4 Modular Lighting
Sustem offers you three units in one. 1. MSL4 is an
Ultra Quiet light tower and trailer equipped with a 30 ft
tower, four 1000 watt metal Halide lamps and your
choice of two different Ultra Quiet power uints. The
power units are self contained and can be easily
removed or installed on the light tower trailer
2. a. YLT6010DE power unit is powered by a
Yanmar 10 h.p. diesel operating at 3600 rpm. It comes
complete with a receptacle panel, running time meter
and an internal 20 gallon fuel tank.
This power unit can be used on the MSL4 light tower
mounted on a separate trailer, or operated as a
staionary power unit.
b. LLT6012DE power unit is powered by a Lister
12 h.p. diesel operating at 1800 rpm. It comes com-
plete with a receptacle panel, running time meter and
an internal 35 gallon fuel tank.
This power unit can be used on the MSL4 light tower
mounted on a separate trailer, or operated as a
staionary power unit.
3. MD6 is an over-the-road trailer with one of the two
power units listed above mounted on it. The trailer is
equipped with a standard DOT trailer light package,
jack stand and safety chains.
SPECIFICATIONS
MLS4Y & MLS4L
TOWER
Height 30 Feet
Rotation 360 degrees
LIGHTS
Type Metal Halide
Number/Wattage 4/1000
TRAILER
Axle Capacity 2200lbs
Tires 215/75-15
Hitch Type 1-7/8 to 2 1/8" Ball
YLT6010DE
ENGINE/GENERATOR
Make/Model Yanmar - L100AE
Fuel/Cooling Diesel/Air
Displacement 406 c.c.
HP @ 3600 10
Starting System 12 volt DC
Fuel Tank 20 gallons
Generator WINCO 6000
Continuous Watts 5500
Type Rotating Field
LLT6012DE
ENGINE/GENERATOR
Make/Model Lister - LPA3
Fuel/Cooling Diesel/Air
Displacement 1088 c.c.
HP @ 1800 12
Starting System 12 volt DC