Napoleon Fireplaces GDS60N - Manual (Page 2)

2
W415-0788 / A / 09.22.09
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
TABLE OF CONTENTS
1.0 INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 DIMENSIONS 5
2.2 GENERAL INSTRUCTIONS 5
2.3 GENERAL INFORMATION 6
2.4 RATING PLATE 7
2.5 CARE OF GLASS 8
2.6 SHIPPING BRACKET 8
3.0 VENTING - MODEL GDS60 9
3.1 VENTING LENGTHS AND COMPONENTS 10
3.2 TYPICAL VENT INSTALLATIONS 11
3.3 SPECIAL VENT INSTALLATIONS 13
3.3.1 PERISCOPE TERMINATION 13
3.3.2 CORNER TERMINATION 13
3.4 VENT TERMINAL CLEARANCES 14
3.5 VENTING APPLICATION FLOW CHART 15
3.6 DEFINITIONS 16
3.7 ELBOW VENT LENGTH VALUES 16
3.8 TOP EXIT HORIZONTAL TERMINATION 17
3.9 TOP EXIT HORIZONTAL TERMINATION 18
3.10 REAR EXIT HORIZONTAL TERMINATION 19
3.11 TOP OR REAR EXIT VERTICAL TERMINATION 21
4.0 INSTALLATION PREPARATION - MODEL GDS60 23
4.1 ORIFICE REPLACEMENT 23
4.2 CHANGING A TOP VENT TO A REAR VENT 24
5.0 INSTALLATION 25
5.1 MINIMUM CLEARANCE TO COMBUSTIBLES 25
5.2 WALL AND CEILING PROTECTION 26
5.2.1 HORIZONTAL INSTALLATION 26
5.2.2 VERTICAL INSTALLATION 27
5.2.3 HORIZONTAL AIR TERMINAL INSTALLATION - MODEL GDS60 27
5.2.4 VERTICAL AIR TERMINAL INSTALLATION - MODEL GDS60 28
5.3 APPLIANCE VENT CONNECTION - MODEL GDS60 29
5.4 MOBILE HOME INSTALLATION - MODEL GDS60 29
5.5 GAS INSTALLATION 29
5.6 OPTIONAL WALL SWITCH / THERMOSTAT 30
5.7 B-VENT SPECIFICS - MODEL GS60 30
5.7.1 CHIMNEY INSTALLATION 30
5.7.2 INSTALLING "B" VENT 31
5.7.3 B-VENT 31
5.7.4 COMBUSTION AIR 31
5.7.5 ADDING VENT SECTIONS 32
5.7.6 INSTALLING FLASHING AND STORM COLLAR 33
6.0 FINISHING 34
6.1 FRONT CAST REMOVAL 34
6.2 GLASS DOOR INSTALLATION AND REMOVAL 34
6.3 GLASS / DOOR REPLACEMENT 35
6.4 LOG PLACEMENT 35
6.5 LOGO PLACEMENT 36
6.6 SWITCH AND BRACKET INSTALLATION 37
7.0 OPTIONAL BLOWER INSTALLATION 38
8.0 WIRING DIAGRAM 39
9.0 OPERATION 40
9.1 OPERATING INSTRUCTIONS 40
9.2 OPERATING INSTRUCTIONS - FOR YOUR SAFETY READ BEFORE OPERATING 41
9.3 LIGHTING INSTRUCTIONS 41
9.4 ANTI CONDENSATION SWITCH 41
10.0 ADJUSTMENT 42
10.1 PILOT BURNER ADJUSTMENT 42
10.2 VENTURI ADJUSTMENT 42
10.3 FLAME CHARACTERISTICS 42
10.4 RESTRICTING VERTICAL VENTS - MODEL GDS60 42
11.0 MAINTENANCE 43
12.0 REPLACEMENTS 44
13.0 TROUBLE SHOOTING 48
14.0 WARRANTY 51
15.0 SERVICE HISTORY 52