York DM150 - Manual (Page 9)

127408-YIM-B-0606
Unitary Products Group 9
LIMITATIONS
These units must be installed in accordance with the follow-
ing:
1. Local building codes, and
2. Local gas utility requirements
3. Local plumbing and waste water codes, and
4. Other applicable local codes.
Refer to Tables 1 & 2 for unit application data.
After installation, gas fired units must be adjusted to obtain a
temperature rise within the range specified on the unit rating
plate.
If components are to be added to a unit to meet local codes,
they are to be installed at the dealer’s and/or customer’s
expense.
Size of unit for proposed installation should be based on heat
loss/heat gain calculation made according to the methods of
Air Conditioning Contractors of America (ACCA).
This furnace is not to be used for temporary heating of build-
ings or structures under construction.
This product must be installed in strict compliance
with the enclosed installation instructions and any
applicable local, state and national codes including,
but not limited to, building, electrical, and mechani-
cal codes.
The furnace and its individual shut-off valve must be
disconnected from the gas supply piping system
during any pressure testing at pressures in excess
of 1/2 PSIG.
Pressures greater than 1/2 PSIG will cause gas
valve damage resulting in a hazardous condition. If it
is subjected to a pressure greater than 1/2 PSIG, the
gas valve must be replaced.
The furnace must be isolated from the gas supply
piping system by closing its individual manual shut-
off valve during any pressure testing of the gas sup-
ply piping system at test pressures equal to or less
than 1/2 PSIG.
FIGURE 4 - PREDATOR ® COMPONENT LOCATION
5RRIFXUEVLQHLJKWDQG
IRXUWHHQLQFKKHLJKWV5RRI
FXUEVIRUWUDQVLWLRQLQJIURP
<RUN6XQOLQHŒIRRWSULQWWR
WKH=+6HULHVIRRWSULQWVDUH
DOVRDYDLODEOH ILHOGLQVWDOOHG
DFFHVVRU\
%DVHUDLOVZIRUNOLIW
VORWV WKUHHVLGHV 
DQGOLIWLQJKROHV
&RPSUHVVRU
DFFHVV KLJK
HIILFLHQF\
FRPSUHVVRU
ZFUDQNFDVH
KHDWHU
'XDOVWDJH
FRROLQJIRU
PD[LPXP
FRPIRUW
6HFRQGPRGHO
QDPHSODWH
LQVLGHKLQJHG
DFFHVVSDQHO
7HUPLQDOEORFNIRU
KLYROWDJHFRQQHFWLRQ
3FJMIF@FQVŒFRQWUROERDUG
ZVFUHZFRQQHFWRUIRU7VWDW
ZLULQJDQGQHWZRUNFRQQHFWLRQV
'LVFRQQHFWORFDWLRQ
RSWLRQDOGLVFRQQHFWVZLWFK
)LOWHUDFFHVV
´WKURZDZD\
)LOWHUGULHU
VROLGFRUH
&RQGHQVHUVHFWLRQ
6OLGHRXWPRWRUDQG
EORZHUDVVHPEO\IRU
HDV\DGMXVWPHQW
DQGVHUYLFH
%HOWGULYH
EORZHUPRWRU
3RZHUYHQWRUPRWRU
JDXJHDOXPL
QL]HGVWHHOWXEXODU
KHDWH[FKDQJHUIRU
ORQJOLIH VWDLQOHVV
VWHHORSWLRQ
7ZRVWDJHJDV
KHDWLQJWRPDLQWDLQ
ZDUPFRPIRUWDEOH
WHPSHUDWXUH
,QWHOOLJHQWFRQWURO
ERDUGIRUVDIHDQG
HIILFLHQWRSHUDWLRQ
6OLGHRXWGUDLQSDQ
ZLWKVWHHO´137
IHPDOHFRQQHFWLRQ
&RPSUHVVRUDFFHVV
KLJKHIILFLHQF\FRPSUHVVRU
ZFUDQNFDVHKHDWHU
7RROOHVV
GRRUODWFK
6LGHHQWU\SRZHU
DQGFRQWUROZLULQJ
NQRFNRXWV