Banks Power Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Power Systems- PowerPack & Stinger Systems w_ EconoMind (LB7 & LLY) '01-05 (PDA) Compatible w_ Optional PowerPDA - Manual (Page 43)

Notification
The Banks Ram-Air Filter comes
pre-oiled and no oiling is
necessary for initial installation.
Service the filter as specified in
this Section of the manual. 1.
Service Banks Ram Air Filter every
50-100,000 miles on street-driven
applications. Service more often in
off-road or heavy-dust conditions.
If an air-filter restriction gauge is
installed, then clean the element
when the air-filter restriction gauge
enters the restrictive red zone. See
Figure 54.
2.
Use Banks Ram Air Filter cleaning
system (part # 90094), available from
Gale Banks Engineering to service
the Air Filter. Follow the instructions
included with the cleaning system
to clean and re-oil your Banks Ram
Air Filter. No gasoline cleaning, No
steam cleaning, No caustic cleaning
solutions, No strong detergents, No
high pressure car wash, No parts
cleaning solvents. Any of these No’s
can cause harm to the cotton filter
media plus SHRINK and HARDEN the
rubber end caps.
CAuTIoN! Extremely fine dust
from agriculture or off-road
use will pull the oil from the
element. Frequent re-oiling of
the element’s clean side might
be required. Completely service
when practicable. For extra
protection use an air-filter sealing
grease on rubber ends of the
element. Service only with Banks
Ram-Air-filter cleaner and Banks
Ram-Air-filter oil.
-END, SEcTION 14-
Section 14
FILTER MAINTENANCE
AIR-FILTER
RESTRICTION
GAUGE
RESTRICTIVE
RED ZONE
Figure 54 Typical air-filter restriction gauge
96776 v.11.0
43