Banks Power Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Tuner- Six-Gun Diesel Tuner, (325 HP Dodge 5.9L Cummins (24-valve) Trucks) '06-07 Compatible with Optional PowerPDA - Manual (Page 28)

28
96810 v.7.0
Your Six-Gun Diesel Tuner displays
the “4,3” diagnostic code (refer to
TROUBLESHOOTING in Section 8 on
how to read codes) when it needs to
learn your transmission configuration.
This always occurs when the Six-
Gun Diesel Tuner is first installed on
the truck. The Six-Gun Diesel Tuner
is equipped with advanced safety
features to preserve your automatic
transmission. One of them is the
capability to detect the occurrence
of transmission slip, and it will
automatically de-rate the engine
output power accordingly.
Before this safety feature can take
effect, the Six-Gun Diesel Tuner needs
to learn that your truck is equipped
with an automatic transmission.
(Please read the “Disclaimer of
Liability” on page 2.)
1.
The following driving test shall
be performed in an area where
speeds over 55mph are legal, safe
and traffic is light. For a vehicle with
a manual transmission, follow Step
2. For a vehicle with an automatic
transmission, follow Step 3. While
driving, listen for any exhaust leaks or
rattles, or intake boost leaks. After the
engine cools, re-tighten clamps and
hoses if leaks are detected.
2.
(Manual trans) To teach the Six-
Gun Diesel Tuner that your truck is
equipped with a manual transmission
drive the truck at a speed over 55
mph for at least 2 minutes. The “4,3”
diagnostic code will be eliminated.
Repeat if necessary to eliminate code.
Proceed to Section 7.
3.
(Auto Trans) To teach the Six-
Gun Diesel Tuner that your truck
is equipped with an automatic
transmission drive the truck at a speed
over 55mph until the torque converter
is locked (the torque converter is
usually locked at speeds over 55mph).
With the torque converter locked and
with turbo boost below 10psig (ie, light
load), maintain the attained speed
steadily for at least 30 seconds. Once
the transmission is learned, the “4,3”
diagnostic code will be eliminated.
Repeat if necessary to eliminate code.
-END, SECTION 5-
Section 5
TRANSMISSION LEARNING